Mercury Other, page #6

Auto blog

Ford announces bevy of recalls, 2 of which are recalls on recalls

Ford has announced five separate recalls, affecting 202,000 vehicles built between 2005 and 2014.
It's not been a great couple of weeks for Ford. On October 30, the company announced a 205,000-unit recall, and yesterday, it was revealed that the Ford brand's year-over-year sales were down over 5,000 units while the company itself was down 3,000 units over through October. Now, the company has announced five separate recalls affecting 202,000 vehicles built between 2005 and 2014.

NHTSA will investigate some Ford Fusion, Lincoln MKZ models for power steering issue

The National Highway Traffic Safety Administration is opening an investigation into the 2010-2012 Ford Fusion, Fusion Hybrid and Lincoln MKZ, the 2012 MKZ Hybrid and 2011 Mercury Milan because the agency has hundreds of complaints of electric power steering failure in these models.
According to NHTSA's data, it has received 508 complaints of the power steering allegedly suddenly malfunctioning and resulting in increased effort to turn the wheel. In four incidents, these failures resulted in loss of control and crashes. According to the reports, in some cases a power steering warning message came on as the fault occurred, and other times the system restored itself by turning off and then restarting the vehicle. NHTSA said it has also received further field report data from Ford, but that information hasn't been publicly released yet.
For the moment, there isn't a recall for this failure on these models. NHTSA is just investigating them to "assess the scope, frequency and safety consequences of the alleged defect," and the agency says an estimated 938,000 vehicles could potentially be affected.

Ford Recalling 70k Escape and Mariner Hybrids for cooling issue

Ford is recalling about 70,209 examples of the 2005-2008 Ford Escape Hybrid and the 2006-2008 Mercury Mariner Hybrid because the cooling pumps for their hybrid systems could fail.
According to the company's defect notice, it's possible for the original "Motor Electronics Coolant (MEC) Pump" to wear out and fail, which would could cause the hybrid system to overheat. If this happens, the vehicle goes into a safety mode that takes away most or all of its power. However, braking and steering still operate normally. After cooling down, the affected models restart normally. The company says that it's not aware of any accidents or injuries related to this problem.
Ford will begin repairing the vehicles in late October, and dealers will be installing improved, brushless pumps on the affected models at no charge to owners. If drivers had their pumps fail before this recall, they can contact Ford for a possible reimbursement. Scroll down to read the recall announcement from the National Highway Traffic Safety Administration or download the full defect notice as a PDF, here.

Ford announces free brake pad offer if customers stop by dealers

These days, when you buy a new car, it's not unreasonable to expect a certain period of free maintenance to come along as well. Sometimes this is through the life of the warranty, in other cases a little less. But Ford Motor Company is going beyond those deals for at least one part of its cars. As of now, if you buy a set of Motorcraft brake pads for a Ford, Lincoln or Mercury model, you get free replacements for as long as you own the vehicle. The offer is good at Ford or Lincoln dealers and Quick Lane Tire & Auto Centers.
"We will replace the pads for as long as you own the vehicle," said Elizabeth Weigandt to Autoblog. She did clarify that the Motorcraft pads are generally for models from the '90s or newer. Also, to take advantage of this program, a person must return to the same dealer each time to get the free parts.
Of course, Ford isn't just handing out brake pads to anyone who walks by; there are certain stipulations. First, the components have to be worn down to less than three millimeters to be eligible, and the buyer still has to pay for the labor to install them. If the model is used as a fleet vehicle for commercial purposes like as a taxi or limousine, this offer also doesn't apply; the same thing for racecars. On the plus side, if you recently bought a set of pads from one of the participating locations, you're still in luck. The deal covers parts purchased as of July 1.

Ford Announces Free Brake-Pad Offer If Customers Stop By Dealers

These days, when you buy a new car, it's not unreasonable to expect a certain period of free maintenance to come along as well. Sometimes this is through the life of the warranty, in other cases a little less. But Ford Motor Company is going beyond those deals for at least one part of its cars. As of now, if you buy a set of Motorcraft brake pads for a Ford, Lincoln or Mercury model, you get free replacements for as long as you own the vehicle. The offer is good at Ford or Lincoln dealers and Quick Lane Tire & Auto Centers. "We will replace the pads for as long as you own the vehicle," said Elizabeth Weigandt to Autoblog. She did clarify that the Motorcraft pads are generally for models from the '90s or newer. Also, to take advantage of this program, a person must return to the same dealer each time to get the free parts. Of course, Ford isn't just handing out brake pads to anyone who walks by; there are certain stipulations. First, the components have to be worn down to less than three millimeters to be eligible, and the buyer still has to pay for the labor to install them. If the model is used as a fleet vehicle for commercial purposes like as a taxi or limousine, this offer also doesn't apply; the same thing for racecars. On the plus side, if you recently bought a set of pads from one of the participating locations, you're still in luck. The deal covers parts purchased as of July 1. "This program reflects our commitment to providing customers with an excellent ownership experience regardless of the age of their vehicle," said Frederiek Toney, President of Ford Customer Service, in the company's announcement of the offer. Scroll down to read the all the details.

NHTSA and Ford investigating steering issues in Crown Vic, Grand Marquis and Marauder

There may be more steering woes for the Ford Crown Victoria. The National Highway Traffic Safety Administration has opened a preliminary evaluation into the Crown Vic and Mercury Grand Marquis from the 2004 to 2007 model years and the Mercury Marauder for the 2004 and 2005 model years because the steering shaft can jam. The issue could potentially affect an estimated 500,000 vehicles.
According to the regulator, there is a possibility that the driver's side heat shield for the exhaust manifold can rust, dislodge, and then wedge into the steering shaft. If this occurs, it leads to a situation where the driver can no longer control the car.
NHTSA has received five complaints of this happening, including one alleged case with an injury. In that situation, the car was driving onto the highway, lost control and rolled over. One occupant was hurt in the accident.

eBay Find of the Day: Craterface's '49 Mercury convertible from Grease

Here is your chance to own your very own piece of greased lightning. Well, not the Greased Lighting, it's actually the black, flamed 1949 Mercury convertible that races against John Travolta in the classic 1978 movie Grease, and it's for auction on eBay Motors.
While it appeared in the film's exciting drag race in a Los Angeles storm drain, the hot rod was reportedly lost until last year, when the seller found it as a shell. He verified that it was the actual car with original builder, Eddie Paul, and sent the car for a complete restoration.
The auction includes original parts like the exhaust tips used in the movie and bent bumper from when it hit Travolta's car in the scene. The restorer recreated the scorpion stickers on the doors, razor hubcaps and license plate. He also installed a 1949 Mercury 255-cubic-inch (4.2-liter), flathead V8 and three-speed manual transmission with overdrive.

Ford finds flex-fuel engine design plays big role in emissions output

How bad is ethanol for your engine? There's been a lot of debate on this issue as the US considers upping the biofuel content in the national gasoline supply from 10 percent (E10) to 15 percent (E15). The ethanol industry and some scientists say higher ethanol blends show no "meaningful differences" in new engines while the oil industry says ethanol creates health risks. Researchers working at the Ford Research and Innovation Center decided to take a closer look at how a wide range of gas-ethanol blends - E0, E10, E20, E30, E40, E55 and E80 - affected the emissions coming out of a flex-fuel 2006 Mercury Grand Marquis. To see the full report, printed in the journal Environmental Science & Technology, requires payment, but there is an abstract and Green Car Congress has some more details. The gist is that, "with increasing ethanol content in the fuel, the tailpipe emissions of ethanol, acetaldehyde, formaldehyde, methane, and ammonia increased." At least NOx and NMHC emissions decreased. The researchers say that the effects are due to the fuel and "are expected for all FFVs," but that the way that a manufacturer calibrates the engine will affect NOx, THC, and NMOG emissions. It's this last bit that's important, since the researchers found, "Higher ethanol content in gasoline affects several fundamental fuel properties that can impact emissions. ... These changes can have positive or negative effects that can depend on engine design, hardware, and control strategy. In addition to direct emissions impacts, higher ethanol content fuel can also provide more efficient combustion and overall engine operation under part-load conditions and under knock-limited higher-load conditions." So, as we head towards more ethanol in our fuel supply (maybe), manufacturers are going to need to learn how to burn it most efficiently.

Ford recalling 370,000 Crown Vic, Grand Marquis and Town Car models

The Detroit News is reporting that Ford will recall some 370,000 Crown Victoria (pictured), Mercury Grand Marquis and Lincoln Town Car vehicles from model years 2005 through 2011, for an issue regarding the lower intermediate steering shaft. 355,000 of the vehicles in question were sold in the US, with the other 15,000 sold in Canada.
The report indicates that corrosion of the lower intermediate steering shaft could cause a "loss of steering," presumably because of a partial or complete failure of the part. The report points out the dealers will inspect and replace the offending steering component for recalled cars, and may also secure a lower steering column bearing and replace the upper intermediate steering shaft as needed. The company is unaware of any reports of the faulty part causing any accidents or injuries.
Ford helpfully lists states in which corrosion is more likely to have taken place, mostly in the Snow Belt, as you might guess. Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Wisconsin, West Virginia, and the District of Columbia are listed.

Preposed class-action lawsuit targets 'defective' MyFord Touch

A national law firm, Hagens Berman Sobol Shapiro LLP, has filed a proposed class action lawsuit whose presupposition is that MyFord Touch is defective. Specifically, the complaint states that the system - as well as the MyLincoln Touch and MyMercury Touch clones - often freeze, fail to respond to voice or touch commands and have issues connecting to mobile phones.
According to Hagens Berman managing partner Steve Berman, MyFord Touch is a theoretically "brilliant idea" that falls short in actual execution. Said Berman in a press release, "In reality, the system is fundamentally flawed, failing to reliably provide functionality, amounting to an inconvenience at best, and a serious safety issue at worst."
Other MFT issues enumerated within the 41-page filing include problems controlling the window defroster, rear-view camera and navigation system. The suit maintains that Ford is aware of the problem but has yet to submit a workable and acceptable solution to MFT customers. Scroll down if you'd like to read the full press release.