Ram 4500 Chassis, page #11

Auto blog

Ram recalling 1,747 diesel trucks for short-circuit risk

Diesel-powered Ram owners, it's recall time. Fiat Chrysler Automobiles has announced a voluntary recall of 1,747 Ram 1500 EcoDiesels from model years 2014 and 2015. Why so few? Well, this campaign is limited to just rear-wheel-drive models. The problem, this time around, is with a battery wiring harness that will chafe against a bracket if it wasn't assembled properly. This chaffing can lead to a short, causing a loss of power (the best-case scenario) or even a fire (probably the worst-case scenario). Fortunately, FCA is unaware of any accidents, fires, or other injuries caused by short circuits. The affected vehicles were sold in both the US and Canadian markets, although the vast majority of the trucks, 1,697 to be precise, are here in the land of the free and home of the brave. The remaining 50 vehicles were sold in Canada, and were likely purchased by those crazy enough to drive a high-torque, rear-drive pickup in a country almost perpetually covered in snow and ice. Regardless of whether your truck has an illuminated dashboard warning light or not, FCA is encouraging drivers of the affected vehicles to report to dealers for a free service when they receive a recall notice. Scroll down for the official press release from FCA, as well as the bulletin from the National Highway Traffic Safety Administration. Statement: Wiring Harness September 9, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 1,747 trucks in the U.S. and Canada to inspect, reroute and replace – as required – their wire harnesses to prevent a potential short-circuit. An investigation by FCA US discovered a battery wiring harness may chafe against a bracket if assembly protocols were not followed. This condition is limited to vehicles equipped with diesel engines and 4x2 drivelines. Such a condition has the potential to cause a short-circuit, which may lead to power loss or fire. The Company is unaware of any related injuries, accidents or fires. The campaign is limited to certain 2014-15 Ram 1500 pickups. It is estimated there are 1,697 in the U.S. and 50 in Canada. Affected customers will be advised next month when they may schedule service, which will be performed at no cost. While the condition may not be present in every vehicle, FCA US urges customers to note the information on their recall notices and respond accordingly. Illumination of a dashboard warning light is among the indicators that the condition is present.

Auto Mergers and Acquisitions: Suicide or salvation?

We love the Moses figure. A savior riding in from stage right with the ideas, the smarts, and the scrappiness to put things right. Alan Mullaly. Carroll Shelby. Lee Iacocca. Andrew Carnegie. Steve Jobs. Elon Musk. Bart Simpson. Sergio Marchionne does not likely view himself with Moses-like optics, but the CEO of Fiat Chrysler Automobiles recently gave a remarkable, perhaps prophetic interview with Automotive News about his interest and the inevitability of merging with a potential automotive partner like General Motors. Marchionne has been overtly public about his notion that GM must merge with FCA. For a bit of context, GM sold 9.9 million vehicles in 2014, posting $2.8 billion in net income, while FCA sold 4.75 million units and earned $2.4 billion in net income, painting a very rosy FCA earnings-to-sales picture. But that's not the entire picture. Most people in the auto industry still remember the trainwreck that was the DaimlerChrysler "merger" written in what turned out to be sand in 1998. It proved to be a master class in how not to fuse two companies, two cultures, two continents, and two management teams. Oh, it worked for the two individuals at both helms pre-merger. They got silly rich. And the industry itself was in a misty romance at the time with mergers and acquisitions. BMW bought Rolls-Royce. Volkswagen Group bought Bentley, Bugatti, and Lamborghini, putting all three brands into their rightful place in both products and positioning. No marriages there, so no false pretense. Finally, Nissan and Renault got married in 1999. A successful marriage requires several rare elements in this atmosphere of gas fumes and power lust. But a successful marriage requires several rare elements in this atmosphere of gas fumes and power lust, the principle part being honesty. Daimler and Chrysler lied to each other. The heads of each unit, the product planners, and finance all presented their then-current and long-range forecasts to each other with less-than-forthright accuracy. Daimler was the far greater equal and no one from the Chrysler side enjoyed that. The cultures were entirely different, too, and little was done to bridge that gap. Which brings me back to the present overtures by Marchionne to GM. "There are varying degrees of hugs," Marchionne stated in the Automotive News piece. "I can hug you nicely, I can hug you tightly, I can hug you like a bear, I can really hug you." Seriously?

FCA recalls over 200k Jeep Cherokees for windshield wiper static

Fiat Chrysler Automobiles is issuing a recall for over 200,000 versions of the 2014 Jeep Cherokee due to a problem with static buildup disabling the windshield wipers. FCA has identified 158,671 units in the United States. Another 18,366 vehicles are estimated to be affected in Canada, a further 3,582 in Mexico, and 26,049 outside of North America. The problem, according to the first statement below, results from static building up if the wipers are operated in dry conditions. The static could mess with the wipers' control module, rendering them disabled. To fix the problem, dealers will be instructed to install a ground strap to the module. In parallel, FCA is also offering incentives to the owners of certain trucks that were subject to recall but for which remedies were not immediately available. To encourage those owners to bring their older vehicles in for the required service, the automaker will disperse $100 prepaid cards for use at their discretion. The program is offered to owners of certain model year Jeep Grand Cherokee, Jeep Liberty, Chrysler Aspen, and Dodge Durango sport-utility vehicles, as well as certain Dodge Dakota and Ram trucks. Owners of the affected Grand Cherokees will have the option instead to take a $1,000 consideration toward the purchase of a new vehicle or for parts and service. The offers are only being extended under certain specific criteria, though. So if you think that could be you, you'll want to read through the conditions in the second announcement below. STATEMENT: CONTROL MODULE August 31, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 158,671 SUVs in the U.S. to help protect their control modules from static buildup that may potentially disable the vehicles' windshield wipers. An investigation by FCA US discovered static buildup may occur if the vehicles' windshield wipers are activated during dry conditions. Significant static buildup may affect a control module that powers the wipers. The Company is unaware of any related injuries or accidents. Affected are model-year 2014 Jeep Cherokee SUVs. An estimated 18,366 vehicles will be recalled in Canada, as will an estimated 3,582 in Mexico and 26,049 outside the NAFTA region. Dealers will install a ground strap to the control module to eliminate the potential for static buildup. Customers will be advised when they may schedule service, which will be performed at no cost.

New Barracuda, Grand Cherokee Trackhawk coming soon

As we write this, Fiat Chrysler Automobiles is conducting a major dealership event in sunny Las Vegas. New vehicles are being announced, redesigned offerings are being teased, and promises are being made to the sprawling company's dealer body. And, as all these announcements are meant to be tip-top secret, they're leaking out left, right, and center. Naturally. FCA is telling its dealers all of the vehicles shown at the Vegas gala will be in showrooms within 12 to 24 months, and that the product offensive will include at least 30 new or significantly refreshed models. Some of those we've known about since FCA boss Sergio Marchionne unveiled his highly ambitious five-year plan in May 2014, while we're hearing about others for the very first time. We've reached out to our sources within FCA, and will update this post as we learn more. It should be noted that while we've tried to rely on concrete sources or corroborations from multiple sources, some of the news here comes from people claiming to have been in attendance and posting in forums like Allpar and Jalopnik's Opposite Lock. Unless corroborated by a mainstream source or confirmed by our own sources within FCA, we're listing each item that comes from a forum. Have those grains of salt at the ready. Chrysler Dodge Durango-sized SUV with stow-and-go was shown. A poster on Allpar Forums claims it had a Durango's interior. New Aspen? Town and Country PHEV confirmed (again). A plug-in minivan was originally announced as part of five-year plan. No news on 200 or 300. Dodge The redesigned Charger will use the Alfa Romeo Giulia's rear-drive platform and, according Automotive News, draw inspiration from 1999's Charger concept car. We're wagering the 24-month time frame specified to dealers will move the new sedan's arrival up from 2018 to mid-2017. Jalopnik's Opposite Lock claims two new Challenger models are coming. Challenger ADR (American Drag Racer) and T/A. ADR should appeal to bracket racers and is more powerful than the SRT Hellcat, while T/A is for track rats, just like Viper T/A. Automotive News claims the legendary Barracuda nameplate will be revived as a Dodge. The Barracuda will be smaller than Challenger, offered as both a coupe and a convertible. Allpar claims it will feature modern styling. A Dodge Durango SRT was announced with 6.4-liter Hemi V8 and rear-drive. Sources within FCA confirmed its arrival with Autoblog. Apparently, dealers were shown an example in B5 Blue.

NHTSA closes investigation on 4.7M FCA power modules, no recall

FCA US hasn't had the best time with recalls as of late. Not only did the company recently agree to greater safety oversight and paid $105 million to the government, that came just days after hacking fears prompted a 1.4-million model recall campaign. However, a recent decision to close an investigation by the National Highway Traffic Safety Administration means that the automaker doesn't have to worry about another major recall possibly affecting 4.7 million vehicles, according to the agency's report (as a PDF). Last September, the Center for Auto Safety petitioned NHTSA to investigate an alleged problem with the totally integrated power module (TIPM) on these FCA US models. The group claimed that a fault with the component could cause a variety of maladies, including stalls, not starting, catching fire, unintended acceleration, and airbag non-deployment. At the time, it also submitted 70 cases where this had reportedly happened. According to NHTSA, "no valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration, or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components." The agency did find signs of an issue with the fuel pump relay in some Jeep Grand Cherokees and Dodge Durangos, but FCA US issued recalls for the problem in September 2014 and February 2015. Without anything else to go on, the Feds don't think it's worth investigating this topic any more.

Certain Chrysler owners eligible for buyback program

Certain car owners whose Chrysler vehicles contain dangerous defects will soon have a way to get rid of their lemons without losing money. As part of an agreement with federal regulators, Fiat Chrysler Automobiles has agreed to buy back more than 500,000 vehicles susceptible to veering out of control without warning at above market-value prices. The deal mainly covers certain models of RAM trucks, the Dodge Dakota pickup and Dodge Durango SUV. Further, owners of more than 1.5 million Jeep Liberty and Grand Cherokees at heightened risk for lethal fires are eligible to trade in their vehicles at above market value or, alternately, get a gift certificate if they prefer to have repairs made. Chrysler has "a heavy responsibility to make sure the products they make are safe for the traveling public," said Mark Rosekind, administrator of the National Highway Traffic Safety Administration. "... Here, we are sending an unambiguous signal to industry that if you skirt the laws or violate the law, or don't live up to the responsibility that consumers expect, we are going to penalize you." The buy-back and trade-in options for motorists come as part of an unprecedented penalty NHTSA slapped against Chrysler for violating federal motor-vehicle safety laws. Chrysler will pay a $105 million fine, the highest ever levied by the regulatory agency. In addition to the buy-backs, Chrysler also agreed to an independent monitor for three years. Investigators had outlined problems in the company's conduct in 23 recalls that affected more than 11 million defect vehicles. As part of a consent-order agreement, Chrysler acknowledged it did not notify vehicle owners of recalls in an effective manner and did not notify NHTSA of safety problems. Though those recalls affected millions of drivers, the buy-back and trade-in options are only for a small portion of the vehicles involved. Because Chrysler struggled to fix the problem and no repair was apparent, Rosekind said the buy-backs are reserved "for customers who didn't have a remedy." Buy-backs are for trucks and SUVs affected by three recalls that occurred in 2013 (recalls 13V-038, 13V-527 and 13V-529), that addressed a rear-axle pinion nut that could come loose and cause a loss of vehicle control. Those recalls covered 579,228 vehicles, including 2009-2012 Ram 1500, 2500, 3500, 4500 and 5500 trucks, 2009-2012 Dodge Dakotas, 2009 Chrysler Aspen and the 2009 Dodge Durango.

FCA recalls 2 million Ram trucks over airbag issues

Airbag issues have prompted Fiat Chrysler Automobiles to issue another pair of recalls. The two separate issues both affect Ram pickups, one campaign stemming from oversensitive sensors, the other from a wiring harness. Between them, the problems affect an estimated combined total of some 2 million units. The first recall affects 2013-15 Ram 1500, 2500, and 3500 trucks, specifically four-door models, manufactured between June 20, 2012, and January 26, 2015. The calibration of the side impact sensor in those affected units may to be too sensitive. As a result, if the door is slammed too hard, the side-curtain airbag and seatbelt pre-tensioner may inadvertently activate. FCA reports that this issue affects an estimated 667,406 units in the United States, plus 153,011 in Canada, a further 8,272 in Mexico, and another 14,847 in markets outside of North America, amounting (in Chrysler's estimation) to less than 0.005 percent of those vehicles produced. The automaker says it is aware of two minor injuries (but no accidents) that may have resulted from the glitch, and is taking action to have the Occupant Restraint Control module recalibrated in the affected units. The second issue also affects Ram pickups, including 1500, 2500, 3500, 4500, and 5500-series models from the 2012 to 2014 model years, built between January 18, 2011, and October 7, 2014, and fitted with the optional Electronic Vehicle Information Center. The problem here stems from a wiring harness in the steering wheel that may rub against a retainer spring in the air bag control module, which in turn could cause an electrical short and deploy the driver's side air bag unexpectedly. In the United States alone, the issue is estimated to affect 1,060,531 units, which will need to be inspected and, where necessary, have their steering wheel wiring harnesses secured, with protective caps added to the ends of the airbag retainer spring. These do not represent the first issues we've seen from Fiat Chrysler in recent days. The automaker recently issued a recall for approximately 1.4 million vehicles to have their Uconnect software updated to prevent hacking. A few days ago it also announced a recall for 350,000 Dodge Journey (and Fiat Freemont) crossovers to secure loose engine covers. And the National Highway Traffic Safety Administration is expected to issue Fiat Chrysler Automobiles a $105-million fine for mishandling other recent recalls and safety issues.

Fiat Chrysler to get $105M fine from NHTSA for recall woes

The National Highway Traffic Safety Administration is about to send a powerful message to automakers doing business in the United States, assuming reports of an upcoming $105 million fine against Fiat Chrysler Automobiles comes to fruition. In addition to the record-setting monetary fine, according to The Wall Street Journal, FCA will have to accept an independent auditor that will monitor the company's recall and safety processes and will be forced to buy back certain recalled vehicles. In other cases, such as with Jeep Grand Cherokee and Liberty models with gas tanks that could potentially catch fire in certain types of accidents, FCA will offer financial encouragement for owners to get their recall work done or to trade those older vehicles in on new cars, according to the report. FCA could reportedly reduce its fines if it meets certain conditions, though those remain unclear at this time. These actions against FCA are being taken after NHTSA began a probe into the automaker over almost two dozen separate instances where the government claims FCA failed to follow proper procedures for recalls and safety defects. Included in those safety lapses are more than 11 million vehicles currently in customer hands. These penalties and fines are separate from the investigation over security problems with Chrysler's Uconnect system that allowed hackers to obtain remote access into key vehicle systems in 1.4 million vehicles. Related Video: Image Credit: Marco Bertorello/AFP/Getty Earnings/Financials Government/Legal Recalls Chrysler Dodge Fiat Jeep RAM Safety fiat chrysler automobiles fine

How to update and secure a vulnerable Chrysler Uconnect system

If you own one of the 1.4 million vehicles affected by the recent Chrysler software recall, you may want to watch this video. In it, we explain how to get the latest infotainment software loaded onto the 8.4-inch Uconnect system. The recall was a response to the findings of researchers who were able to hack into and remotely control a 2014 Jeep Cherokee through its cellular connection. Although Fiat Chrysler has worked with Sprint to plug most of the holes on the carrier side, there are still some vulnerabilities that only this latest software version can patch. Owners have three options to get the update: download it now, wait for a USB stick in the mail, or take the vehicle to an FCA dealer. Chrysler will be sending USB sticks loaded with the software update to customers. Anyone with an internet connection and a USB stick of their own with at least 4 GB capacity can speed things up by downloading the patch from the Uconnect website. We cover that process from start to finish in the video, with the final portion still applicable to those using the FCA-supplied USB stick. If after watching this you still don't want to tackle the patch yourself, you can take your vehicle to the dealer to have it done. Also note that this process is the same for all Uconnect updates, not just the one patching the exploits. Our demonstrator vehicle is a 2015 Ram 1500 pickup. The procedure should be very similar on other products with the 8.4-inch Uconnect system, with only the location of the USB port varying. Once you have the USB stick with the software on it – either after having downloaded it yourself or receiving it in the mail from Chrysler – the installation process is relatively simple. It takes about 15 minutes to perform the update; we edited out the wait in the video. To check whether or not your car's 8.4-inch Uconnect system is running the latest software, go to System Information on the touch screen's Settings page and look at Software Version. The update related to the recall is version 15.17.5. Related Video: Recalls Chrysler Dodge Jeep RAM Safety Technology Infotainment Videos Original Video hacking

FCA issuing software update for 1.4M vehicles to prevent hacking

In the wake of a Jeep Cherokee being hacked remotely while on the road through its Uconnect infotainment system, FCA US is now issuing a software update for 1.4 million vehicles in the United States. Affected customers will receive a USB stick in the mail with the improved version; owners can check this website to see if their cars are affected. A large variety of models with FCA's 8.4-inch touchscreen infotainment system are affected. They include the 2015 Chrysler 200, 2015 Chrysler 300, 2015 Dodge Charger, and 2015 Dodge Challenger; 2013-2015 Dodge Viper; 2013-2015 Ram 1500, 2500, and 3500; 2013-2015 Ram 3500, 4500, and 5500 chassis cab; 2014-2015 Jeep Grand Cherokee and Cherokee; and 2014-2015 Dodge Durango. According to FCA in its announcement, the new software "insulates connected vehicles from remote manipulation." As of July 23, the company also "fully tested and implemented within the cellular network" additional security to prevent access to many of a vehicle's systems. FCA US says that it's conducting this campaign out of an abundance of caution and disputes the notion that there's a defect with these vehicles. Beyond the demonstration of the hack in the Cherokee, the automaker says that it's unaware of any other reports of these attacks actually happening. Related Video: Statement: Software Update July 24, 2015 , Auburn Hills, Mich. - FCA US LLC is conducting a voluntary safety recall to update software in approximately 1,400,000 U.S. vehicles equipped with certain radios. The recall aligns with an ongoing software distribution that insulates connected vehicles from remote manipulation, which, if unauthorized, constitutes criminal action. Further, FCA US has applied network-level security measures to prevent the type of remote manipulation demonstrated in a recent media report. These measures – which required no customer or dealer actions – block remote access to certain vehicle systems and were fully tested and implemented within the cellular network on July 23, 2015. The Company is unaware of any injuries related to software exploitation, nor is it aware of any related complaints, warranty claims or accidents – independent of the media demonstration.