Ram 3500 4WD Tradesman, page #9

Auto blog

FCA goes all-in on Jeep and Ram brands on cheap gas bet

It's no surprise that as SUV and truck sales remain strong in the wake of unusually cheap gas, Jeep and Ram sales are taking off. What is a surprise is that FCA CEO Sergio Marchionne thinks that cheap gas will be a "permanent condition," and feels strongly enough about it to change up North American manufacturing plans. Jeep appears to be the biggest beneficiary of the product realignment. In addition to increasing the sales estimates for the brand worldwide upwards to 2 million units a year by 2018, the brand will get a flood of investment for new product and powertrains. Consider the Wrangler Pickup to be part of the salvo, as well as the Grand Wagoneer three-row announced in 2014 as part of the original five-year plan. The Wrangler four-door will get at least two new powertrains, a diesel and mild hybrid version, in its next generation. That mild hybrid powertrain may utilize a 48-volt electrical system like the one that's being developed by Delphi and Bosch – which the suppliers think will be worth a 10 to 15 percent fuel economy gain at a minimum. Down the road, in the 2020s, the Wrangler could adopt a full hybrid system. The diesel powertrain is planned for 2019 or 2020. The Ram 1500 is also pegged to receive a mild hybrid system, again potentially based on 48-volt architecture, sometime after 2020. Lastly, Jeep and Ram will take over some of the production capacity of existing plants. The Sterling Heights, MI, plant that builds the Chrysler 200 will now build the Ram 1500; the Belvidere, IL, facility that produces the Dodge Dart will take over Cherokee output; the big Jeep facility in Toledo, OH, will be used for increased Wrangler demand. In 2015, according to FCA's numbers, car and van demand went down by 10 percent, but SUV demand went up 8 percent and truck demand 2 percent. Considering that these are high-margin vehicles, FCA can't ignore the math. FCA also won't build any new factories to supplement production to meet demand, but instead are reshuffling production priorities. Think of it this way: FCA is gambling on cheap gas being a permanent part of our lives, at least into the 2020s. By doubling down on SUVs and trucks, the company stands to win big, unless a spike in gas prices changes the landscape. FCA isn't talking about a Plan B, so they're all in. It'll be interesting to see how this plays out.

2015 Ram ProMaster recalled for ignition switch issue

The Basics: Ram is recalling a total of 18,121 examples of the 2015 ProMaster with production dates between October 1, 2014, and June 17, 2015. These include 16,114 of them in the US, 1,498 in Canada, 503 in Mexico, and 6 outside the NAFTA region. The Problem: The ignition switch can intermittently lose electrical contact, and this can potentially cause the vans to stall. If the problem occurs, the vehicles might also lose functionality of the airbags, anti-lock brakes, electronic stability control, and instruments. Injuries/Deaths: None reported. The Fix: Dealers will replace the ignition-switch contact holder. If You Own One: FCA filed the recall with the National Highway Traffic Safety Administration on November 25, and it has 60 days to notify owners about the campaign under federal rules. Until the repair, the company says that turning the ignition off and then back on can fix this problem if the switch loses contact. RECALL Subject : Intermittent Loss of Ignition Switch Contact Report Receipt Date: NOV 25, 2015 NHTSA Campaign Number: 15V799000 Component(s): ELECTRICAL SYSTEM Potential Number of Units Affected: 16,114 All Products Associated with this Recall Vehicle Make Model Model Year(s) RAM PROMASTER 2015 Details Manufacturer: Chrysler (FCA US LLC) SUMMARY: Chrysler (FCA US LLC) is recalling certain model year 2015 Ram ProMaster vans manufactured October 1, 2014, to June 17, 2015. The affected vehicles have an ignition switch that may experience an intermittent loss of electrical contact. CONSEQUENCE: An intermittent loss of contact can result in a vehicle stall and/or a partial or complete loss of the air bags, anti-lock brakes, electronic stability control and/or instrument panel cluster. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash. REMEDY: Chrysler will notify owners, and dealers will replace the ignition switch contact holder block, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R64. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. Statement: Ignition Contacts November 27, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 16,114 full-size vans in the U.S.

Ram Rebel X Concept wishes it could go offroad at SEMA [w/video]

Given the truck's defiant spirit, the Ram 1500 Rebel simply can't appear subdued. For the Rebel X Concept at the SEMA Show, Mopar goes all out to make the already tough looking pickup even more brash. The Rebel X certainly stands out in the vast ocean of customs at SEMA with its orange-tinted Copper paint. Thanks to 35-inch Toyo tires on 17-inch beadlock wheels underneath flared fenders, there's also no question that this truck wants to be offroad. In addition to the vibrant body, the front end wears black trim, and a concept, two-piece skid plate underneath offers a little visual contrast. The interior actually tones down the bold look slightly by combining black leather seats with Rebel X embroidery and Copper stitching. Rather than being just about style, Mopar beefs up the 5.7-liter V8 with a cold-air intake and cat-back exhaust. The division also tweaks the suspension by fitting a concept, air-ride setup. Get a better look at the Rebel X by checking out our gallery from SEMA above or the video below of the modded pickup at the show. Related Video: Ram Rebel X The Ram 1500 Rebel makes a statement by itself. Mopar helps proclaim its all-terrain credentials even louder with the Ram Rebel X, a full-size pickup outfitted with a catalog of production parts and accessories. The unique dark Copper exterior extends to the functional sport performance hood, accented with a Matte Black graphic trimmed with a Mopar Blue tracer. Mopar wheel flares extend over the 35-inch Toyo tires, which wrap around 17-inch cast-aluminum beadlock wheels that equip the 1500 Rebel for rumbles over off-road terrain. Painted functional beadlock rings with fasteners are also featured on the beadlock wheels, with Mopar center caps providing another highlight to the rims. The front features the distinctive Rebel grille with the RAM logo painted in Satin Black and a concept two-piece skid plate. The bed is stylishly secured with a soft tri-fold tonneau cover, and a Mopar dual exhaust bed step helps reach tools or equipment stored in the rear. Black tubular side steps provide a lift into the interior, which features prototype Katzkin leather seats embroidered with the Rebel X name outlined in silver in a black field, with a blue field for the "X." Copper stitching accents the armrest and steering wheel. Additional features inside include all-weather slush mats, a pedal kit and door sills.

Mopar highlights wild SEMA creations, AWD Challenger Concept

Thanks to 15,345 square feet of display area, FCA US' Mopar division certainly has ample space to display its parts and accessories at the SEMA Show. To lure attendees to check out all of those cars and components, the company is now revealing ten tuned vehicles for this year's aftermarket event. This isn't even the brand's whole fleet for the show, but it includes some major highlights for Dodge and Ram fans. A lack of traction traditionally makes rear-wheel-drive muscle cars dismal to drive when the weather gets slippery, but the Dodge Challenger GT AWD Concept (above) solves that age-old problem at SEMA. In addition to powering all four wheels through an eight-speed automatic, it boasts an angry-looking, wide-body kit with aggressively flared wheel arches. The asymmetrical stripe with Header Orange accents also adds some extra panache to the Destroyer Grey and Matte Black color scheme. The coupe can back up the macho look thanks to the Scat Pack 3 Performance Kit that adds 75 horsepower and 44 pound-feet of torque to the 5.7-liter V8. However, before you get too excited about driving one this winter, FCA US spokesperson Ariel Gavilan tells Autoblog: "It is only a concept." Mopar isn't done tuning Dodges for SEMA. The Charger Deep Stage 3 shows what's possible with the company's catalog by packing the Scat Pack 3, strut tower braces, coilover suspension kit, and bigger brakes. Meanwhile, the blacked-out Dart GLH Concept tries to harken back to the style of the famous Omni GLH by fitting a red-accented body kit, including a Mopar Performance aluminum hood. If the standard Ram 1500 Rebel is somehow too subdued, check out the Rebel X (right) in a vibrant shade called Copper. To be ready for anything offroad, it wears some muscular flares to fit 17-inch beadlock wheels and 35-inch Toyo tires. A concept, two-piece front skid plate protects the front. Drivers should also be comfortable no matter where they drive thanks to prototype Katzkin leather seats and a concept air-ride suspension. Chrysler enjoys some mods, as well. The 300 Super S has suave style with Matte Cerulean paint, concept 22-inch wheels, and a grille with little Mopar Ms dotted around it. Performance also sees a boost with a tuned engine, bigger brakes, and coilover kit. The gray 200 S Mopar is similarly stylish with a complete body kit, including a conceptual, dual-vented hood. Fiat and Ram's commercial models aren't left out of the SEMA fun, either.

Towing with the 2016 Ram lineup [w/video]

I do not tow things. Ever. Yet I recently found myself at the Fiat Chrysler Automobiles proving grounds in Chelsea, MI, where I'd be testing the hauling capabilities of Ram's current product range. This experience was not only a perfect education for a towing novice like me, but allowed me to tow far more weight than I'd ever consider hauling the real world, and all within the safe confines of the Chelsea Proving Grounds. There was an extremely diverse array of vehicles at my disposal, including Ram's gasoline- and diesel-powered offerings with trucks ranging from the 1500 on up through the 5500 Chassis Cab, as well ProMaster vans. Beyond that, FCA brought out a number of vintage Dodge pickups for me to play with, while also working with Case IH to provide a track-loader I could test. I put together a range of videos covering everything from the classics to the production trucks to the construction equipment. And despite some technical difficulties – you'll notice a distinct lack of in-car videos, with blame going to a corrupted micro SD card – I've assembled ten videos that give an up-close look at Ram's offerings. 2015 Ram ProMaster City Let's start small. The ProMaster City only has a towing capacity of 2,000 pounds. That's a reasonably impressive figure for a van that uses the same powertrain as a Chrysler 200. The 2.4-liter four-cylinder and nine-speed automatic weren't really bothered with the extra weight added by the trailer. Even when accelerating at freeway speeds, the ProMaster City didn't feel out of breath or hampered by its load. That said, the rear of the van was unloaded, which probably wouldn't be the case for most consumers. It's unclear how the City would feel if its driver were taking advantage of the max payload (1,883 pounds) and towing. 2015 Ram ProMaster 1500 To be polite, the Ram ProMaster is a difficult vehicle to like. Its awkward seating position is bus-like and lacks the visibility enjoyed by the Ford Transit or the utter driving comfort of the Mercedes-Benz Sprinter. Its 3.0-liter, four-cylinder turbodiesel engine, meanwhile, is something of an anomaly. While it's potent for a four-cylinder diesel, producing 295 pound-feet of torque and 174 horsepower, those numbers don't feel all that impressive when loaded down. The model I tested was barely using half of its 5,100-pound maximum towing weight and was loaded down with just 500 of its 3,620-pound payload. Yet it lacked the pluckiness of the smaller City.

Ram recalling 65k trucks for rear-axle heat treating

A problem with the rear axle has promoted Fiat Chrysler Automobiles to recall a selection of Ram trucks. The campaign affects 2015-16 Ram 1500 series trucks – specifically those manufactured between June 17 and September 28, 2015. All told, that amounts to over 65,760 units across the United States. The issue stems, according to the statements below, from the rear axle shaft. Some of those trucks may have not had those axle shafts properly heat-treated, which could cause them to fracture and separate from the wheel. And that, it should go without saying, could lead to a crash. FCA states that most of the vehicles in question are in dealer hands, but while the manufacturer says it is aware of one accident to have resulted from the issue, no injuries have been reported. The owners of the affected vehicles will be notified to bring their trucks in to their local dealership to have them inspected. If necessary, the dealership with replace the rear axle assembly. This recall follows three prior (but unrelated) ones, also issued for Ram pickups, that between them affected well over a million units. Related Video: RECALL Subject : Incorrectly Heat Treated Rear Axle Shaft Report Receipt Date: OCT 15, 2015 NHTSA Campaign Number: 15V661000 Component(s): POWER TRAIN Potential Number of Units Affected: 65,760 Manufacturer: Chrysler (FCA US LLC) SUMMARY: Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Ram 1500 trucks manufactured June 17, 2015, to September 28, 2015. The affected vehicles may have been built with rear axles that were incorrectly heat treated. CONSEQUENCE: If the rear axle shaft was not properly heated treated, it may fracture and a wheel separation could occur, increasing the risk of a crash. REMEDY: Chrysler will notify owners, and dealers will inspect the vehicles and replace the axle assemblies, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R59. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. ### Statement: Heat-treating October 27, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 65,760 U.S.-market trucks – most of which are in dealer hands – to inspect and replace, as required, their rear axle shafts or rear axles.

2016 Green Truck of the Year, Commercial Green Car of the Year finalists

Not only are commercial-grade haulers getting more green love lately, they're getting more different kinds of green love. The 2016 Green Truck of the Year, the second time the award has been handed out, is being decided by judges from Green Car Journal and the San Antonio Auto & Truck Show. This year the award is joined by the new 2016 Commercial Green Car of the Year, which crowns one of the little vans increasingly used by small business as cargo and delivery vehicles. The Green Truck of the Year finalists are the Chevrolet Colorado Duramax (pictured), Ford F-150, GMC Canyon Duramax, Nissan Titan XD, and Toyota Tacoma. The first three of those were on last year's list, but since they are completely new or upgraded for 2016 - Ford with its all-aluminum body, the General Motors twins with the new diesel Duramax engine - they qualify for entry again. The Ram 1500 EcoDiesel won last year. The Commercial Green Car finalists are the Chevrolet City Express, Ford Transit Connect, Mercedes-Benz Metris, Nissan NV200, and Ram ProMaster City. You can read more details in the presser below, and the awards will be announced in San Antonio sometime during the show from November 19-22. San Antonio Auto & Truck Show Announces 2016 Green Truck of the Year and Commercial Green Car of the Year Finalists SAN ANTONIO, Oct. 22, 2015 /PRNewswire/ -- Green Car Journal and the San Antonio Auto & Truck Show have announced finalists for the 2016 Green Truck of the Year™ and 2016 Commercial Green Car of the Year™ awards. The Green Truck of the Year™ nominees are the Chevrolet Colorado Duramax, Ford F-150, GMC Canyon Duramax, Nissan Titan XD, and Toyota Tacoma. Vying for the all-new 2016 Commercial Green Car of the Year™ award are the Chevrolet City Express, Ford Transit Connect, Mercedes-Benz Metris, Nissan NV200, and Ram ProMaster City. "Over the past few decades, new car models have benefitted from design and technology improvements that have brought higher fuel efficiency and greater levels of environmental compatibility," said Green Car Journal and CarsOfChange.com Editor and Publisher Ron Cogan. "With models like these ten deserving finalists, we're witnessing the pickup and light commercial vehicle field enjoying the same attention." The new Commercial Green Car of the Year™ award is part of an expanded awards program presented at this year's 2015 San Antonio Auto & Truck Show.

Mopar teases four of 'nearly 20' SEMA Show concepts

Yesterday it was Chevrolet. Today, Mopar has dropped some SEMA knowledge, releasing a quartet of teaser images that give us some indication of what kind of cars, trucks, and crossovers Fiat, Chrysler, Dodge, Jeep, and Ram will be showing in Las Vegas. Like Chevy, Mopar's concepts utilize both production and concept accessories, although Fiat Chrysler has gone a bit more indepth on at least one of its concepts. Immediately, the most tantalizing teaser is the one shown above. Yes, that's the back of a Challenger, and aside from the bright orange accents on the gray body, you should take notice of the badge mounted on the spoiler – yes, that says "GT AWD." To be honest, such a vehicle wouldn't be a huge shock, as both the Challenger's LX platform-mates, the Dodge Charger and Chrysler 300, are offered with all-wheel-drive options. Still, adding such a vehicle to the production cycle would give Dodge a leg up on the rear-drive only Ford Mustang and Chevrolet Camaro. Aside from that concept, FCA has also released teasers of a Ram-based concept, a 300-based concept, and what we're guessing is a Fiat 500X. We can't wait to see what the actual Fiat concept has to do with kiteboarding. As for the 300 and Ram, there's not a lot of hints on what sort of styling details they'll contain. The Chrysler has additional LED accents and what we're guessing is matte blue paint, while the Ram is based on a Hemi-powered 1500 with Rebel styling cues. This is just a very tiny sample of Mopar's final SEMA roster, which include "hundreds" of parts. There should also be a total of 20 vehicles covering all four former Chrysler Group brands, as well as Fiat. Naturally, we'll have plenty to report on each vehicle once the SEMA show kicks off in the next couple weeks.

FCA names Mike Manley head of Ram brand

Sergio Marchionne seems to revel in shifting the numerous portfolios of the senior executives who work under him. Case in point: the latest round of hat-swapping announced by Fiat Chrysler Automobiles. Several appointments have been made at the top levels of the group, chief among them a new head of the Ram truck brand. That role will now fall to Mike Manley, who will also retain his responsibilities for the Jeep brand and as COO for the Asia-Pacific region. With his hands busy enough as it is, we'd imagine that much of the day-to-day will fall to Robert Hegbloom. He had Manley's new job until now – but will still remain head of the Ram brand for North America, where the bulk of its business is conducted. Along with the shift in leadership for the Ram brand, FCA also named Reid Bigland as head of fleet operations for North America. Bigland is also responsible for sales in the same region, and for the Alfa Romeo brand here as well. The company also named Tim Kuniskis to the Group Executive Council, charged with overseeing all the passenger-car brands in North America – including Dodge, Chrysler, and Fiat. While it was at it, FCA also named Al Gardner as head of network development for North America, and Jason Stoicevich as Bigland's deputy for US fleet and small-business sales. All these appointments take effect immediately. FCA US ANNOUNCES LEADERSHIP CHANGES October 5, 2015 , Auburn Hills, Mich. - FCA US today announced several leadership team moves in support of changes at the Fiat Chrysler Automobiles N.V. (FCA) Group Executive Council (GEC) level. The moves were made to ensure proper representation of all of FCA's major brands on the GEC, the highest management level decision making body within the FCA organization. Earlier today, the following moves were announced at the GEC level. - Mike Manley is appointed Head of Ram Brand. Manley will retain his current GEC responsibilities as APAC Chief Operating Officer and Head of Jeep Brand. - Reid Bigland is appointed Head of NAFTA Fleet. Bigland will continue his current GEC responsibility for NAFTA Sales & Alfa Romeo. - Timothy Kuniskis becomes a member of the GEC and assumes responsibility for NAFTA Passenger Car Brands, consisting of Dodge and SRT, Chrysler and FIAT. In addition, the following appointments were made to the North American leadership team. - Robert Hegbloom continues as Head of Ram Brand for North America, now reporting to Manley.

Fiat previews new Toro sport-utility pickup

Fiat is preparing to roll out a new midsize pickup. We've seen spy shots of the prototype running around, but heavily camouflaged as it was, we didn't get much indication of what it would look like – and even less about its name. But now the Italian automaker has given us an indication of both. Previewed in the teaser image above is the forthcoming new Fiat Toro. The vehicle is billed as a "sport-utility pickup," which Fiat touts as a new segment, though there are already plenty of vehicles out there that aim to blur the line between pickup and SUV. Models like the Honda Ridgeline and Chevy Avalanche come to mind, but the Toro is likely to be smaller than either – more like the long-gone Ford Explorer Sport Trac that bridged the gap between the old truck-based Explorer and the Ranger pickup or the Subaru Baja. Whatever it ultimately looks like, the Toro will be limited – at least initially – to the Latin American market. There it's set to be introduced early next year by Fiat Automoveis Brasil, which also offers the Strada pickup car. Whether the Toro ever makes it out into other markets remains to be seen, but we wouldn't hold out too much hope of getting a Ram version this far north as Chrysler doesn't think there's a market for compact or mid-size pickups in America to replace the old Dakota. Related Video: