Ford F750, page #67

Auto blog

Ford finds flex-fuel engine design plays big role in emissions output

How bad is ethanol for your engine? There's been a lot of debate on this issue as the US considers upping the biofuel content in the national gasoline supply from 10 percent (E10) to 15 percent (E15). The ethanol industry and some scientists say higher ethanol blends show no "meaningful differences" in new engines while the oil industry says ethanol creates health risks. Researchers working at the Ford Research and Innovation Center decided to take a closer look at how a wide range of gas-ethanol blends - E0, E10, E20, E30, E40, E55 and E80 - affected the emissions coming out of a flex-fuel 2006 Mercury Grand Marquis. To see the full report, printed in the journal Environmental Science & Technology, requires payment, but there is an abstract and Green Car Congress has some more details. The gist is that, "with increasing ethanol content in the fuel, the tailpipe emissions of ethanol, acetaldehyde, formaldehyde, methane, and ammonia increased." At least NOx and NMHC emissions decreased. The researchers say that the effects are due to the fuel and "are expected for all FFVs," but that the way that a manufacturer calibrates the engine will affect NOx, THC, and NMOG emissions. It's this last bit that's important, since the researchers found, "Higher ethanol content in gasoline affects several fundamental fuel properties that can impact emissions. ... These changes can have positive or negative effects that can depend on engine design, hardware, and control strategy. In addition to direct emissions impacts, higher ethanol content fuel can also provide more efficient combustion and overall engine operation under part-load conditions and under knock-limited higher-load conditions." So, as we head towards more ethanol in our fuel supply (maybe), manufacturers are going to need to learn how to burn it most efficiently.

Enterprise customer billed $47k for Mustang stolen from rental lot

A weekend rental of a Ford Mustang GT Convertible sounds like a nice, relaxing way to burn some gas, but one Nova Scotia woman's two-day rental is turning into a months-long headache. In early October, Kristen Cockerill picked up the Mustang from Enterprise Rent-A-Car, and she returned it the following day as stipulated by the rental contract. Unfortunately, she dropped the car off on a Sunday - a day on which the particular Enterprise office is closed - and the car ended up being stolen overnight.
Now, two months later, CBC reports that Cockerill received a bill from Enterprise for the full replacement of the car totaling $47,271 (a base 2014 Mustang GT Convertible currently costs $40,349 in Canada). As it turns out, the fine print in the contract says that the renter is responsible for cars dropped off after hours until it can be inspected the next business day - this is also reflected on the key drop seen in the news report video, which states "vehicles returned after hours are the responsibility of the renter until inspected on the next business day."
It's not clear how much, if any, of that amount Cockerhill will be responsible for once her insurance company gets involved, but if the insurance company refuses to pay, Enterprise will bill the amount to the credit card she provided during her rental. While this ordeal is far over for Cockerhill, it's a good reminder for the rest of us to always read the fine print.

After Years Of Delays, Rear Visibility Requirements Move Closer To Reality

Regulations that would require automakers to improve rear-view visibility on all new cars and light trucks are nearing completion after six years of delays. The U.S. Department of Transportation sent its proposed rear-visibility rules to the Obama administration for review on Christmas Day. The White House Office of Management and Budget now must finalize the regulations. The rule are intended to minimize the risk of pedestrian deaths from vehicles in reverse, a type of accident that disproportionately affects children. Already in 2014, two children have died from cars backing over them, driven in each case by the children's father. Specifics of the Transportation Department's proposal are not available during the review, but the rules are expected to compel automakers to install rear-view cameras as mandatory equipment on all new vehicles. That's what safety advocates have wanted all along. Thought they were pleased the proposed ruling had finally been issued, there was some worry Friday the final rules would omit the rear-view camera mandate. "We're encouraged, but we're also a little concerned about speculation the rear-view camera may not be in there," said Janette Fennell, the president and founder of Kids and Cars, a nonprofit organization dedicated to protecting children in and around vehicles. "I'm wondering where that might be coming from." On Thursday, The Automotive News had reported the possibility the new standards could offer an alternative to rear-view cameras, such as redesigned mirrors, that improved visibility. The Office of Management and Budget typically completes its reviews of new rules in 90 days, although that can be extended. OMB officials said Friday they do not comment on pending rules. The intent of the rules is to enhance rear visibility for drivers and prevent pedestrian deaths. Approximately 200 pedestrians are backed over in the United States each year, according to estimates from the National Highway Traffic Safety Administration. Accidents Mostly Affect Children Roughly half the victims are children younger than age five. A government analysis concluded approximately half the victims -– 95 to 112 -– could be saved with new regulations. Yet the rules have arrived at a glacial pace. President George W. Bush signed legislation that had been passed with bipartisan Congressional support in 2008. But automakers have fought the idea of adding rear-view cameras, saying it is too expensive.

This unique '64 Mustang was Edsel Ford II's first car

You probably had the same dream when you were a teenager. Your sixteenth birthday is coming up, or Christmas, or maybe both, and all you want is a muscle car to call your own. That dream has come true for some, and one of them was none other than Edsel Ford II.
Henry Ford's great grandson turned 16 on December 27, 1964 - two days after Christmas and eight months after the original Mustang went on sale. And that's just what was waiting for him in the driveway, courtesy of his father (and reigning chief executive) Henry Ford II.
The specially-prepared pony car had a pearlescent cream paintjob with narrow blue racing stripes, functional hood scoop, chrome trim, Euro-spec fender-mounted mirrors, a blue leather and aluminum interior, a monogrammed fuel cap... and a 289-cubic-inch V8 under the hood.

How Ford's light lab keeps the sun shining on the new Mustang just right [w/video]

Anyone who's bought one of those old school metal shift knobs knows they're really cool until they sit in a parking lot in the sun for a few hours. Then they're not cool at all. Likewise, features such as the aluminum dash on the 2015 Ford Mustang can be all kinds of neat right up until the sun hits it just the right way and sends shards of blinding light through the cabin. The Ford Visual Performance and Evaluation Lab is where engineers figure out how to make sure that doesn't happen.
Cars like said Mustang are parked inside the 30-foot reflecting dome under 6,000 watts of lights that can mimic the sun at any time of day and in any weather condition. Engineers can then spend cold, overcast days inside, testing for interior legibility, glare and reflections on every interior and exterior surface as if it were bright and sunny. They can also learn how a car's sheetmetal and colors will look out of doors, all year round.
Ford showed off the lighting lab without the music and interviews three years ago when the Explorer was being prepared. You can watch it at work again in the video below, and read about it in the press release below that.

Ford bringing C-Max Solar Energi Concept to CES

Solar energy might not be enough to power a usable electric vehicle on its own, but that doesn't mean it can't lend a helping hand. And that's what Ford has in store for the Consumer Electronics Show opening next week in Las Vegas.
Ford has essentially taken its C-Max Energi plug-in hybrid and fitted it with the latest in solar panel technology developed by SunPower, acting like a magnifying glass to capture as much of the sun's energy as possible. So you get the benefit of an electric vehicle, with the range assurance of a hybrid, without needing to draw from the grid.
Ford estimates that a day of charging in the sunshine will give the C-Max Solar Energi concept the same full charge as the production PHEV, with a total range of 620 miles - 21 of which can be run on electric power alone. Otherwise the vehicle - which remains a concept for the time being - is identical to the existing C-Max Energi. The top-selling model in Ford's growing hybrid and electric vehicle portfolio helps put Ford just behind Toyota among the top seller of hybrids in America. Scope out the images in the gallery above and the video clip and press release below for a closer look.

Ford To Unveil Solar Hybrid Concept Car At CES

Ford plans to unveil at this month's International CES gadget show a solar-powered concept car that offers the same performance as a plug-in hybrid but without the need for a plug. The C-Max Solar Energi Concept car uses a gasoline engine combined with a gizmo that acts like a magnifying glass to concentrate the sun's rays on the vehicle's roof-mounted solar panels. The automaker says the vehicle's estimated combined city-highway mileage is 100 miles (160 kilometers) per gallon. The U.S. auto maker says that by using solar power instead of an electric plug, a typical owner will reduce their annual greenhouse gas emissions by four metric tons. The company says it sold about 85,000 hybrid or electric vehicles in 2013, including 6,300 units of its C-Max Energi plug-in hybrid. The sun-ray concentrator was developed by researchers at the Georgia Institute of Technology and uses what is known as a Fresnel lens, which concentrates light but can be made thinner than a conventional lens. A full day of sunshine is equivalent to a four-hour battery charge, or 8 kilowatts, Ford says. On a full charge, it should have a range of 620 miles (997 kilometers), the same as the C-Max Energi. The concept car also comes with a plug-in port for standard electric charging. Ford says that 75 percent of all trips made by an average driver could be powered by the sun. After showing off the concept car at the convention in Las Vegas Jan. 7-10, Ford Motor Co. says that it will test the vehicle with institute researchers to determine if it's feasible for mass production. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. Related Gallery 2013 Ford C-Max Energi Test Drive View 9 Photos Green CES Ford Alternative Fuels Fuel Efficiency Solar Cars solar car

Jay Leno and Lee Iacocca reflect on 50 years of Ford Mustang

Lee Iacocca oversaw the birth of the Ford Mustang back in the 1960s, rocketing the new pony car nameplate into million-unit sales territory in its initial go-round and cementing its place in the history books. Thus, we were immediately drawn to this latest episode of Jay Leno's Garage, in which the funnyman hosts Iacocca for a look at the origins of Ford's most iconic sports car. The legendary auto exec is looking notably more frail than when we last saw him, but if we're being asked around as a video guest when we're 89 years old, we'll consider that evidence of a life well lived.
Serial No. 0001 is on hand for the occasion for Jay's romp through history, as is the historic Mustang 1 showcar from 1962. Of course, the all-new 2015 Ford Mustang GT (in prototype form) makes an appearance at the end of the episode with chief engineer Dave Pericak, as well. Get some, below.

Ford predicts it will finish 2013 as top-selling US brand

Ford is ready to call the ball on its 2013 sales totals, predicting a first-place finish for units sold in the US for a single brand. The company anticipates selling more than 2.4 million vehicles when all vehicle sales over the last 12 months have been tallied, repeating the victory it trumpeted over Toyota last year.
According to Ford's accounting, it sold 329,677 more vehicles than did Toyota in 2012. This year, the Blue Oval expects that margin to grow; through the end of November, Ford says it has outsold Toyota by 396,041 units.
Retail sales of Ford products are projected to exceed 1.7 million units for 2013 (the best retail result in 6 years for the company), with passenger cars accounting for 600k of that total. The redesigned Fusion is expected to crest the 290k mark, and the Fiesta is said to be ready to hit a model-record of 70k-plus. Meanwhile, utility vehicles and trucks are still paying a lot of bills in Dearborn, with the new Escape racking up an expected 300k sales and F-Series trucks chugging along at 688,810 units sold thru November.

2015 Ford F-150 to get 2.7-liter EcoBoost?

As we prepare for the arrival of the all-new, next-generation Ford F-150, rumors about the new truck are picking up steam. Naturally, many of said rumors aren't just related to the way the truck will look (it's expected to take design cues from the Atlas concept shown above), they're tied to what's going to motivate the Blue Oval mainstay, with Ford's EcoBoost range likely to play an increasingly key role. While we're still expecting the current 3.5-liter, twin-turbocharged V6 to retain its position as a premium alternative to Ford's naturally aspirated V6 and V8, a Canadian automotive news site is proposing that the Dearborn automaker is also preparing a new, more fuel-efficient downsized EcoBoost option.
Autos.ca is reporting that a new, 2.7-liter, twin-turbocharged V6 could find its way into the lighter, aluminum-intensive truck. The new engine supposedly makes use of asymmetrical turbos to generate 320 horsepower and 370 pound-feet of torque - substantially more impressive numbers than the current 3.7-liter base engine's 302 ponies and 278 lb-ft - while offering improved fuel economy and emissions. The new 2.7 EcoBoost (internally dubbed "Nano") isn't expected to supplant the naturally aspirated V6 as the F-150's base engine, it's expected to slot in above directly it.
Naturally, we're prescribing more than a few grains of salt to go with these rumors, at least until Ford debuts the next F-150 at the 2014 Detroit Auto Show, a reveal we'll be covering in a mere two weeks.