Chevrolet Sedan Delivery, page #13

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

GM recalls 3,300 pickups and SUVs for new ignition-switch issue [UPDATE]

UPDATE: A statement from GM about the recall has been added below. The exact total of vehicles affected is 3,296, including 3,073 of them in the US. General Motors isn't letting an ignition-switch problem grow into a massive scandal again. The automaker is recalling about 3,300 North American trucks and SUVs. They are: the 2014 Chevrolet Silverado and GMC Sierra and the 2015 Chevy Suburban and Chevy Tahoe, as well as 2015 model heavy-duty pickups, the Detroit News reports, citing an Associated Press story. The issue appears to have been caught fairly quickly. In this case, the keys can get stuck in the "start" position and then slip to "accessory" if bumped. This is because the ignition lock gears have an outer diameter that's larger than the specifications allow. When that happens the engine shuts off, and the driver loses assistance to the steering and brakes. The airbags might also be affected. The vehicles get a new ignition-lock housing to fix the problem. According to the Detroit News, an employee who experienced the problem with the switch discovered the issue, and this person then let officials at the automaker know as part of the Speak Up for Safety program. A total of five reports of the fault were discovered. However, there are no cases of injuries or crashes. The claims to the automaker's resolution program eventually tallied that GM's previous ignition switch problem included 124 deaths and 275 injuries. The company also had to recall millions of vehicles and pay significant fines to the US government. GM Statement General Motors is recalling 3,073 full-size trucks from the 2014 and 2015 model years in the U.S. Some of these vehicles may have an ignition lock actuator gear with an outer diameter that exceeds specifications, which may make turning the ignition key difficult. The ignition key could get stuck in the "start" position. This may be more likely at higher interior ambient temperatures. If the vehicle is driven with the key stuck in the "start" position, and the vehicle experiences a significant jarring event or the vehicle's interior temperature cools, the ignition lock cylinder could move out of the "start" position, rotate past the "run" position, and move into the "accessory" position, leading to loss of power steering assist, power brakes and potentially air bag deployment in certain crashes. Dealers will replace the ignition lock housing.

The U-2 spy plane needs high-performance cars to help land

Typically, aircraft deploy their landing gear from three main points. Most military aircraft, for example, deploy two gears at the back and one forward, like a tricycle. Some civilian aircraft flip the layout, with two in front and one in back - tail-draggers. The U-2 Dragon Lady is wildly different than any of these. With a 103-foot wingspan but a body that's just 63-feet long, the layout of the U-2 makes a traditional landing setup infeasible. Instead, the U-2 utilizes a pair of wheels, one up front and one in back. With such a bizarre layout, landings are so tough that since the U-2's earliest flights at Area 51, the US Air Force has used high-performance chase cars to guide the pilot down safely. The landing process isn't over there, though. As this video from Sploid shows, balancing out the aircraft to fit the detachable "pogos" – think training wheels for spy planes – is a comical procedure requiring a number of airman using their full body weight to even out the U-2. This video also recaps some of the great vehicles that have served as chase vehicles for this legendary spy plane. They include Chevrolet El Caminos, and the Fox-body Ford Mustangs so favored by the California Highway Patrol. For the last several years, the USAF has utilized products from General Motors, using fourth-generation Chevy Camaros, before switching over to the Pontiac GTO and most recently, the awesome Pontiac G8. It's fair to say that if you're a gearhead in the Air Force, this is the job you want. Check out the video, embedded up top. News Source: Sploid via YouTubeImage Credit: Sploid Chevrolet Ford GM Pontiac Military Performance Videos

GM re-recalls 11k SUVs

General Motors is recalling a bunch of previously recalled SUVs because, well, they still aren't quite fixed. The latest repairs are necessary on 10,974 SUVs in North America, including 9,932 in only the US. Affected models include the 2006-2007 Buick Rainier, Chevrolet Trailblazer, and GMC Envoy; plus the 2006 Trailblazer EXT and Envoy XL. While not listed by NHTSA, a statement by GM to Autoblog says the 2006-2007 Saab 9-7X and Isuzu Ascender are also affected. In these SUVs, it's possible that liquid could get into the driver's door master power window switch module and cause a short circuit. This could potentially lead to a fire, and owners are urged to park the vehicles outside until repaired. GM has been trying to fix this issue for years. It started as an investigation into fires, and that led to a recall for about 250,000 vehicles in cold-weather states. A nationwide campaign came in 2013 for 193,000 of them in the US. Last year, the automaker decided to replace the whole module as a repair. However in a recent investigation of these recalls, GM discovered that this latest group of SUVs never received the new part. According to documents submitted to NHTSA (as a PDF), "Some dealers incorrectly used the labor code associated with module replacement when, instead of replacing the module, they only added a protective coating to the module." To fix things this time, the models finally get the correct component. Related Video: GM Statement General Motors is recalling 9,932 older midsize SUVs in the U.S. because they were mistakenly excluded from an earlier recall. Certain 2006 Chevrolet TrailBlazer EXT and GMC Envoy XL, and 2006-2007 TrailBlazer, Envoy, Buick Rainier, Saab 9-7X and Isuzu Ascender vehicles may continue to have a condition in which the printed circuit board inside the driver's door may corrode and short if exposed to certain fluids such as melted snow containing road salt. GM is aware of four fires but no crashes, injuries or fatalities associated with the expanded recall. The total number of vehicles being recalled, including Canada, Mexico and exports is 10.974. Customers are urged to park these vehicles outside until repairs have been made. GM reported this recall to the NHTSA on September 23.

GM tells owners not to use SUV wipers due to fire risk

General Motors is recalling 31,685 examples of the 2016 Buick Enclave, Chevrolet Traverse, and GMC Acadia because a short circuit in the windshield wiper motor can potentially lead to a fire. Due to the danger, the company is asking owners not to use the wipers until the problem is fixed, according to The Detroit Free Press citing the Associated Press. A manufacturing defect in the wiper motor cover means that the electrical terminals can come into contact and cause a short. The part could "melt, smoke, or catch fire," according to a statement from GM. The company will get them fixed immediately, and dealers will replace the cover. If there's bad weather at the time the owner specifies to get the recall work completed, the automaker will come pick up the crossovers. Depending on parts availability, the automaker will supply a rental car for customers, as well. The issue was discovered at the factory. According to the company's statement, only 6,405 actually made it to customers, and they were notified immediately by overnight letter. The rest were in dealer stock. The affected crossovers carry build dates between August 18, 2015 and September 24, 2015. Of those, there are 29,295 in the US and 1,073 in Canada. GM Statement: General Motors has told the National Highway Traffic Safety Administration that it will recall approximately 29,295 2016 model year Chevrolet Traverse, Buick Enclave and GMC Acadia SUVs in the U.S. because the front windshield wiper motor may overheat when in use because of a manufacturing defect. In some cases, the front windshield wiper motor cover may melt, smoke or catch fire. The approximately 6,405 customers who have taken delivery of these vehicles were notified by overnight letter and are urged to contact a GM dealer as soon as possible to arrange a service appointment. These customers should not use the front windshield wipers until they have been repaired. If weather conditions prevent driving the vehicle without using the windshield wipers, GM will arrange to pick up the vehicle for servicing. If repair parts are unavailable, GM will provide a rental car at no cost until parts become available. The total population, including Canada, Mexico and exports, is approximately 31,685. About 25,280 of these vehicles are in dealer stock and will not be sold until repairs are made.

GM diesel pickups first to undergo extra EPA, CARB testing

The effects of Volkswagen's long-running diesel emissions evasion are starting to spill over to other automakers, but General Motors is taking things in stride. The 2.8-liter, four-cylinder Duramax in the 2016 Chevrolet Colorado and GMC Canyon is the first engine to get extra scrutiny by the Environmental Protection Agency and the California Air Resources Board, Automotive News reports. Rather than just the usual in-lab test, it's also being checked on the road. However, the extra evaluation shouldn't have any impact on when the trucks with his mill hit dealers later this fall. "We're in our final stages of the EPA certification, and our launch is on track," Chevy spokesperson Otie McKinley tells Autoblog. The four-cylinder diesel in the trucks makes 181 horsepower and 369 pound-feet of torque, and the automaker is touting low NOx production. In the announcement for the Colorado's specs, the company calls it "the cleanest diesel truck engine ever produced by General Motors." The tech includes exhaust gas recirculation to lower combustion temperatures and improve emissions. There's also a urea tank like on the bigger diesels for full-size trucks, and it gets refilled in time with oil changes. An indication on the instrument panel lets drivers know when that's needed, too. Even with the more demanding testing, the company doesn't seem too worried about the four-cylinder passing. "Part of our development process is on-road and off-road [laboratory] testing," Scott Yackley, Chevy Trucks assistant chief engineer, said to Automotive News. In the wake of the VW scandal, the EPA has pledged more rigorous testing. Before, on-road emissions evaluations were largely limited to heavy-duty vehicles, but the agency has decided to apply the checks more often to other models. There's also now greater cooperation with Canadian authorities.

Autoblog Minute: 2017 Ford F-Series Super Duty truck reveal

Competition in the heavy duty truck segment heats up as we get our first look at the 2017 Ford F-Series Super Duty lineup. Autoblog's Adam Morath reports on this edition of Autoblog Minute. With commentary from Autoblog's senior editor Greg Migliore and an interview with Doug Scott of Ford Motor Company. Update: This post has been updated to reflect that the entire Ford F-Series Super Duty lineup is new for 2017, not just the F-250 model. Show full video transcript text [00:00:00] Competition in the heavy duty truck segment heats up as we get our first look at the 2017 Ford F-Series Super Duty trucks. I'm Adam Morath and this is your Autoblog Minute. As Ford prepares to release its new Super Duty line to the American worker, we spoke with Doug Scott of Ford's Truck Group to find out what customers can expect from this latest super duty offering: [00:00:30] [Doug Scott Interview] For more on what the changes to Super Duty mean for the segment we go to Autoblog's Greg Migliore: [00:01:30] [Greg Migliore Interview] Will a larger cabin and increased towing capacity help these heavy duty trucks take off like the smaller F150? And, how will the other HD giants, Chevy, GMC, and Ram respond? Truck fans, be sure to sound off in the comments below. For Autoblog, I'm Adam Morath. [00:02:00] Show Logo Autoblog Minute is a short-form video news series reporting on all things automotive. Each segment offers a quick and clear picture of what's happening in the automotive industry from the perspective of Autoblog's expert editorial staff, auto executives, and industry professionals. Chevrolet Ford GMC RAM Truck Autoblog Minute Videos Original Video ford f-250 f-250 super duty

Weekly Recap: Bentley Bentayga leads luxury SUV charge at Frankfurt

The Bentley Bentayga is launching a new era of ultra high-end sport utility vehicles that will see luxury makers vie for the world's richest and most exclusive customers. The Bentayga is Bentley's first SUV, and it will formally debut next week at the Frankfurt Motor Show. It's loaded with Bentley's best technology and features, led by a 600-horsepower W12 engine. The mission is simple: stop giving up sales to other companies by not having an SUV in its portfolio. "It creates an entirely new category of ultra-luxury SUV, where there are currently few rivals," IHS Automotive analyst Ian Fletcher said in a report. But Bentley and the Bentayga will soon face stiff competition. Archrival Rolls-Royce will produce its own crossover to be built in England, though timing is unclear. Lamborghini has approved plans for a ute that will be assembled in Italy and launch in 2018. Even the sportier British brands are getting into the market. Aston Martin will make a crossover version of the DBX concept shown earlier this year in Geneva, and Jaguar is launching the F-Pace crossover, which will debut in Frankfurt. These new entries will invigorate a segment that's comprised of the Mercedes G63 AMG and the Land Rover Range Rover SV Autobiography, and Bentley is poised to grab a large share of it, Fletcher noted. IHS forecasts Bentayga sales could hit 3,000 units per year in 2017 and 2018, pushing total Bentley sales to more than 10,000 in the next few years. The vehicle will also get plug-in hybrid and diesel variants to widen its reach. The Bentayga is a sales grab, for sure, but Bentley took care to ensure the SUV remained true to the brand. It's laden with the top-shelf wood, leather, and metal, and it comes standard with an expansive panoramic glass roof. It also has intelligent features like electronic night vision and an optional responsive off-road system that can be configured to adapt to eight different settings. It's a different kind of Bentley, but it's a harbinger of things to come for the world's richest luxury makers. Other News & Notes Toyota debuts next-gen Prius Toyota revealed the next-generation of its iconic fuel-sipping hybrid, the 2016 Prius, at an event in Las Vegas. The car promises 10-percent gains in fuel efficiency, though actual figures – and even powertrain specifics – were not revealed. We estimate that could mean about 56 miles per gallon in city driving and 53 on the highway.

Europeans ask Chevy to bring Volt back to Europe

A group of French fans is asking for a jolt of support from General Motors to get the 2016 Chevrolet Volt across the pond. The Association Amperistes et Amis des Vehicules Rechargeables is running a Change.org petition that currently has 383 signatures out of a goal of 500. While the attempt is admirable, it's probably going to take a lot more than several hundred people for the model to make a return to the continent after the poor showing of the Opel Ampera – first-gen Volt's European cousin. The group's major argument for bringing a version of the second-gen Volt to Europe is that consumers need "an intermediate choice between expensive or range-limited pure electric cars and plug-in hybrids with a miserable electric range." Furthermore, such a vehicle would prod the competition to produce similarly efficient electrified models. They also lavish praise on the abilities of the Ampera for its long EV driving range. The supporters aren't entirely kind to GM in the petition, though, and claim the company excluded the original car from marketing efforts there. The Ampera actually enjoyed a strong European launch with more orders than initially expected and briefly topped the best-sellers list among EVs there. It was even named 2012 European Car of the Year. Those halcyon days didn't last long, and by 2014 sales fell off to a trickle. The waning reception caused GM's decision not to introduce a version of the new 2016 Volt there or in Australia. Related Video:

Weekly Recap: Tesla loses money, still dominates the news

Some people get an inordinate amount of attention. In politics, it's Donald Trump. In football, it's Jim Harbaugh. And in the auto world, it's Elon Musk and his always-fascinating electric car company, Tesla Motors. General Motors is spending $877 million to upgrade a factory. So what! US auto sales are up. Who cares? Tesla has a metal snake that will recharge your car! So was the week in Tesla – er, the industry. Snarkiness aside, Tesla did dominate the news cycle, led by the announcement the company lost $184 million in the second quarter. Tesla also said it expects to deliver between 50,000 and 55,000 vehicles this year, and is preparing for a full launch of the Model X crossover in September. Musk also made news during the earnings call by simply not answering a question about ride sharing, leading to speculation Tesla could be considering its own operation. While the financials were the arguably the most important company news, reports of a Model S cyber hacking were more compelling fodder for Tesla followers. Researchers were able to attack the sedan and bring it to a stop, though they required access to the car first. Tesla says it already has deployed a remedy for the situation. On a lighter note, Tesla published a video of its metal charger prototype that autonomously uncoils like a snake to power up the company's vehicles, provoking plenty of humorous comments and comparisons. Watch it and decide for yourself. While some of this might seem trivial, much of Tesla's recent attention has been warranted. It's the first startup US automaker in decades to launch from nothing and actually gain traction in the market. Sure, Musk is a lightning rod and Tesla always seems to be in the spotlight. But amid all of the publicity, it easy to lose sight of the new reality: Tesla is a force. OTHER NEWS & NOTES 2016 Chevy Volt lights up 106 MPGe The Chevy Volt's vitals are looking healthier for 2016. The second-generation plug-in hybrid racks up a gaudy 106 miles per gallon equivalent, which is an increase of eight MPGe from the 2015 model. The new Volt can travel 53 miles on electricity, a significant jump from the 2015 Volt's 38-mile range. The new car also has a 420-mile total range when factoring in the capability of the gasoline engine, which is 40 miles greater than the current car offers.