2006 Volvo S60 2.5t Sedan 4-door 2.5l, Auto, Sunroof on 2040-cars

Auto blog

Regulators consider adding more carmakers to Takata recall

Volkswagen's diesel emissions scandal has been getting a lot of press recently, but the Takata airbag inflator affair could be grabbing headlines again soon. According to Bloomberg, the National Highway Traffic Safety Administration is contemplating an expansion to the campaign that could add seven automakers to the 12 already affected. They are Jaguar Land Rover, Mercedes-Benz, Spartan Motors, Suzuki, Tesla, Volvo Trucks, and VW Group. To be clear, there's no recall for any of these automakers, yet. The government is simply asking for a full list of vehicles that each of them have with Takata-supplied inflators containing ammonium nitrate propellant. The agency is concerned this substance could play a roll in the ruptures. "NHTSA is considering not only whether to issue an administrative order that would coordinate the remedy programs associated with the current Takata recalls, but also whether such an order should include expansion of the current recalls," the letters say. All seven can be viewed, here. From a report supplied by Takata, the government already knows that the company supplied 887,055 inflators with ammonium-nitrate propellant to VW and 184,926 of them to Tesla. In an incident during the summer, a side airbag allegedly burst in a 2015 VW Tiguan. In early September, NHTSA put out a revised report that there were 23.4 million inflators to be replaced in 19.2 million vehicles in the US. An earlier accounting from the agency had about 34 million of the parts in 30 million cars. High humidity is still believed to be among the biggest risk factors for the ruptures. Although, if ammonium nitrate also gets the blame, some already recalled models might need to be repaired again. Related Video:

Volvo to unveil permanent high-beam headlamp technology [w/video]

Volvo will be showing off its Active High Beam technology at the Geneva Motor Show next week. The system will allow drivers to use their high beams all the time and adds another responsibility to the cameras mounted by the rearview mirror, making them detect traffic ahead, whether it be another car or a truck or motorcycle and in the same lane or oncoming. When a vehicle is detected, a special projector in the Xenon lamps can block out only the portion of the high beam that would impair the other driver. Volvo says the system is accurate down to a 1.5-inch margin around another object.
Active High Beam will be fitted to the Volvo S60, V60 and XC60 and we have to assume they mean the non-US versions of those cars. Audi has a similar technology that it calls "matrix beam lighting," and due to the way the US Federal Motor Vehicle Safety Standard code is written, such active control of high beams is verboten on cars sold here.
The Swedish brand also plans to present a collision-avoidance technology it's calling a "world-first." The press release below has more information and the accompanying video demonstrates the lighting tech.

Volvo finds a way to turn body panels into batteries [w/video]

One of the problems with designing an electric vehicle is figuring out where to fit the battery pack. Volvo - as a part of a European Union research project - is working on a way around this issue by replacing standard parts with lightweight components that double as batteries on both conventional and plug-in vehicles. The image above shows one such piece on a Volvo S80. While looking like nothing more than a carbon fiber plenum cover, the piece is actually a battery pack that can store and supply enough energy for the car's entire 12-volt power system.
The parts are made by sandwiching super capacitors (which can charge faster than standard batteries) in between layers of carbon fiber. They can then be formed to replace numerous body panels such as the decklid, roof or door panels. Volvo says that the replacing the body panels and batteries with these nano batteries can help reduce the vehicle's weight by as much as 15 percent. It has taken more than three years just to design the batteries, so there's no telling when, or if, we'll ever see this technology used on a production vehicle. Scroll down for a video and press release on Volvo's innovative battery technology.