2004 Volkswagen Passat Gl Sedan 4-door 1.8l on 2040-cars

Auto blog

VW recalls another 6,700 vehicles over fuel leak [UPDATE]

UPDATE: An earlier version of this post suggested that the expanded recall involved an additional 44,658 units, when VW tells us that is in fact the total number - adding a further 6,679 to the original recall of 37,979. The text below has been updated accordingly, with our apologies for the confusion. It was a little over a month ago that Volkswagen issued a recall for some 38,000 vehicles over a potential fuel leak. Now the German automaker and the National Highway Traffic Safety Administration have expanded that recall, affecting even more vehicles for the same issue. The problem revolves around a sealing cap at the fuel rail, which could fail and cause fuel to leak into the engine compartment, thereby increasing the risk of a fire. This time around, VW is calling in a selection of Jettas, Passats, Golfs, GTIs, Beetles and Beetle Convertibles, all of them from the 2014 and 2015 model years (except the Golf and GTI, of which only 2015 models are being recalled). The recall now affects an estimated additional 6,679 units, which (in addition to the 37,979 recalled previously) brings the total up to 44,658 vehicles across the United States. RECALL Subject : Fuel Leaking Into Engine Compartment Report Receipt Date: JAN 23, 2015 NHTSA Campaign Number: 15V028000 Component(s): FUEL SYSTEM, GASOLINE Potential Number of Units Affected: 44,658 Manufacturer: Volkswagen Group of America, Inc. SUMMARY: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2014, to November 20, 2014, and 2014-2015 Beetle and Beetle Convertible vehicles manufactured March 31, 2014, to November 27, 2014. A sealing cap at the fuel rail may fail, allowing fuel to leak into the engine compartment. CONSEQUENCE: A fuel leak, in the presence of an ignition source, can result in a vehicle fire. REMEDY: Volkswagen will notify owners, and dealers will replace the fuel rails with new parts, free of charge. The recall is expected to begin in early February 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24BL. Note: This recall expands and supersedes recall 14V-809 (Volkswagen recall number 24Bi) and only affects vehicles not previously repaired under that campaign.

Autoblog Minute: VW finds CO2 'irregularities', Takata dropped by automakers, SEMA recap

Volkswagen's diesel emissions scandal gets a new wrinkle, US regulators hit Takata Corporation with a substantial fine, and we head to Las Vegas for a look at tuner paradise at the 2015 SEMA show. Autoblog senior editor Greg Migliore reports on this edition of Autoblog Minute Weekly Recap. Show full video transcript text [00:00:00] Volkswagen's diesel emissions scandal gets a new wrinkle. US regulators issue a significant fine to Takata Corporation. And we take a peek inside tuner paradise at the 2015 SEMA show. I'm senior editor Greg Migliore and this is your Autoblog Minute Weekly Recap. The VW diesel emissions scandal, first brought to light in September, gets a new wrinkle, as an internal investigation by the German automaker revealed [00:00:30] irregularities in CO2 emissions that could affect approximately 800,000 vehicles. VW estimates the issue could pose a 2-billion euro economic risk. VW claims that most of the vehicles affected have diesel engines, but industry analysts say a 1.4-liter gas engine is also affected. VW says that fuel consumption figures were set too low during the CO2 certification process. During all of this, sales of some diesel-powered Volkswagen, Audi, and Porsche models [00:01:00] have been halted. Takata Corporation is back in the news in connection with its deadly airbag scandal. Federal regulators fined Takata $70 million. If the parts supplier does not comply, the fine could balloon to $200 million. Takata was also dropped this week by its biggest customer, Honda. And now, Toyota and Mazda will be following Honda's lead in dropping Takata. We're also hearing that Mitsubishi and Subaru are considering a switch in air-bag inflator suppliers. SEMA 2015 [00:01:30] came and went. We saw offerings from Mopar, like the AWD Challenger concept. Honda unveiled a Ridgeline that it will race at the Baja 1000, which gives us a hint at what future production model could look like. The celebrity presence was also felt in Vegas as it always is. Kid Rock brought a Duramax Diesel Chevy Silverado, and Acura restored and presented Ludacris with his now famous 1993 Acura Legend. Those are the highlights from the week that was. Be sure to come back on Saturday for my full recap, [00:02:00] where I'll have some added insight into Hyundai's foray into the luxury sector. For Autoblog, I'm Greg Migliore. Autoblog Minute is a short-form video news series reporting on all things automotive.

VW recalls 1.1M Jetta, Beetle models in US, China over suspension fears

Volkswagen is recalling about 1.1 million vehicles in China and North America in a newly announced campaign affecting the rear suspensions on some models. For the US, the action covers about 442,265 vehicles, including 400,602 examples of its 2011-2013 Jetta and 41,663 units of the 2012-2013 Beetle and Beetle Convertible. According to Reuters, the recall affects a further 126,000 vehicles in Canada and about 581,090 in China, including related market-specific models like the Sagitar.
The problem can occur if the affected models have a collision to the rear or the side-rear of the vehicle. It's then possible for the trailing arms on the torsion-beam rear suspension to be damaged. If the harm isn't noticed, then the part could fracture while driving. Obviously, a broken rear suspension is going to have an adverse effect on handling.
To fix things, VW dealers will inspect the trailing arms on the models, and they will all receive a sheetmetal part that will make a distinctive sound if broken in the future. If already damaged, the entire torsion beam will be replaced. Obviously, this work will be done at no charge to owners.