Diesel One-owner Highway Miles Timing Service At 126k No Reserve. Bid Now! on 2040-cars

Auto blog

VW decides against active-cooling system for e-Golf lithium battery

When the 2015 VW e-Golf was introduced at the LA Auto Show last year, VW said it would come with a water-cooled battery. During the Detroit Auto Show, when the car was trotted out again, VW released a new press release that stripped out the "water-cooled" language, but this change went unnoticed. During a recent VW event in Germany, a friend from Green Car Reports realized that the battery on display did not seem to have any water-cooling mechanisms. That set us off on a bit of a sleuthing and we have now learned that VW is not going to include any active cooling in the upcoming e-Golf. In fact, the company is entirely confident that this car - because of what it's designed to do - doesn't need it. "The need for a cooling system wasn't there" - VW's Darryll Harrison VW has been working on an electrified Golf for ages now, and so changes to the plan are to be expected. But battery cooling is vitally important not just to keep the car operating properly but because when things get too hot, there can be serious public relations problems. Nissan began testing a new battery chemistry for the Leaf in 2013 after an uproar from warm-weather EV drivers in Arizona who were experiencing worse-than-expected battery performance. The Leaf has always used an air-cooled battery, which is another way to say that there is no active cooling system (more details here). Tesla CEO Elon Musk once said this approach is "primitive." So, why is VW following the same path? We asked Darryll Harrison, VW US's manager of brand public relations west, for more information, and he told AutoblogGreen that VW engineers discovered through a lot of testing of the Golf Mk6 EV prototypes, that battery performance was not impacted by temperatures when using the right battery chemistry. That chemistry, it turns out, is lithium nickel manganese cobalt oxide (NMC) in cells from Panasonic. These cells had "the lowest self-warming tendency and the lowest memory effect of all cells tested," Harrison said. He added that VW engineers tested the NMC cells in places like Death Valley and Arizona and found they didn't warm very quickly either through operation, charging (including during fast charging) or through high ambient temps. "The need for a cooling system wasn't there," Harrison said.

VW stock plummets as Euro markets open

The fallout from Volkswagen's installation of an emissions "defeat device" on nearly 500,000 diesel-fueled models in the US is already hitting the automaker hard on the German stock exchange. At one point, the share price plummeted 23 percent to erase the equivalent of $17.6 billion in value. Things eventually bounced back slightly to a still severe 19.23 percent loss, according to Bloomberg as of this writing. The scandal couldn't come at a worse time for chairman Martin Winterkorn. The VW supervisory board takes up the issue of renewing his contract on September 25, Bloomberg reports. If things get bad enough, the door could be open for a new boss to step in. Dealers in the US might start feeling the pain from this, as well. Affected 2015 VWs that are still at showrooms are now under a stop sale. Until the issue is straightened out, the Environmental Protection Agency isn't certifying the company's 2016 diesel models with the 2.0 TDI, either. The diesel emissions problem was first discovered by research from West Virginia University and the International Council on Clean Transportation. In some cases, the engines can produce 40 times more nitrogen oxides than allowed. The automaker could be on the hook for $18 billion in fines for the breach, but the actual figure is expected to be lower. In response, Winterkorn has issued a public apology and ordered an independent investigation into what happened. The EPA and California Air Resources Board have also been looking into the situation. This could become an international problem, though. According to The Detroit News, European authorities might begin similar inquires to check the automaker's diesel emissions there.

Car Club USA: CleanMPG Northwest Rally

Car Club USA heads to Los Angeles for the CleanMPG Northwest Rally, where a group of like-minded hypermiling enthusiasts led by Wayne Gerdes attempts to drive from Los Angeles, CA, to Bend, OR, on one tank of fuel. For this challenge, Wayne tapped some of the most accomplished hypermilers in the world, including Guinness World Record holder Bob Winger and Mike Sefton, "the most fuel efficient driver in all of Canada." It doesn't take long for the competition to get heated. "They're not aggressive enough, and it's not going to save them anything by being soft right now," says Gerdes as the group attempts to navigate the Interstate traffic. "Driving in Los Angeles is a hyper miler's nightmare," says Winger. The trip will challenge both car and driver, while putting the latest fuel-efficient tech to the test. Wayne is piloting the Volkswagen Golf Sportwagen TDI, Sefton drives the Audi A3 TDI, and Winger attempts the trek in a Honda Accord Hybrid. It's diesel versus hybrid tech on this fuel-efficient trip of a lifetime. Each Car Club USA episode features a different car club or event from across the US, where passionate owner communities gather to share automotive experiences and embark on incredible adventures. From Main Street cruises to off-road trails, catch all the latest car club activity on Autoblog. Green Audi Honda Volkswagen Alternative Fuels Fuel Efficiency Green Culture Green Driving Driving Diesel Vehicles Hybrid Car Club USA Videos Original Video cleanmpg