2014 Volkswagen Cc Sport Pzev on 2040-cars

Auto blog

BMW, Ferrari, VW cars use tungsten mined by terrorists

Bloomberg Markets is reporting that BMW, Volkswagen and Ferrari have been using tungsten ore sourced from Columbia's FARC rebel terrorists. The extensive story focuses on Columbia's illegal mining trade and calls into question the provenance of the rare ore that is used not only in crankshaft parts production, but is also found in the world's computing and telecommunications industry for use in screens.
The ore is mined by the FARC (Fuerzas Armadas Revolucionarias de Colombia, or Revolutionary Armed Forces of Colombia - People's Army), and exported to Pennsylvania, where it is refined. The refined ore is then sent over to Austria, where a company called Plansee turns it into a finished product. Now, it's important to note that we aren't talking about the world's supply of tungsten here. In 2012, Plansee's American refinery purchased 93.2 metric tons of tungsten, valued at $1.8 million. That's peanuts, with the entire Colombian tungsten mining industry producing just one percent of the world's supplies.
That doesn't make indirectly supporting FARC any more acceptable, though. BMW, VW and Ferrari are all committed to not accepting mineral supplies from the Democratic Republic of Congo, which is also in the grips of a guerrilla insurrection funded, in part, by illegal mining. The same commitment would figure to extend to Colombian mining, but as BMW points out, it's difficult for a multi-national manufacturer to know where every item in its supply chain comes from. A company spokesperson says as much, telling Bloomberg, "These few grams out of the billions of tons of raw materials passing through the BMW supply chain are of no practical relevance."

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

Chrysler and Fiat offering $1,000 rebates to VW owners as Marchionne gets tough

The throw-down between Fiat CEO Sergio Marchionne and Volkswagen has heated up in earnest. According to Bloomberg, Fiat and Chrysler are now offering current Volkswagen owners in the US $1,000 rebates to trade in their ride. It's the latest in a series of shots Marchionne has taken at his German rival. As you may recall, the Fiat executive entered into a spat with Volkwagen board chairman Ferdinand Piëch and CEO Martin Winterkorn in October after the duo called for Marchionne's resignation from presidency of the European Automotive Manufacturers Association (AECA). At the time, the Volkswagen executives were quoted as saying Fiat would not survive the European economic downturn.
In response, Marchionne called the German executives "reprehensible," and accused Volkswagen of using a pricing strategy that has created created a "bloodbath" in the EU. Volkswagen has taken to steep discounting to carve out ever-larger slices of market share in Europe, but the company has a much smaller foothold in the US. Marchionne may be trying to hit Volkswagen where the manufacturer is weakest with the new Fiat new incentive program.
Late last week, the Fiat executive was voted to a second term as ACEA president.