2004 Toyota Tundra “sr5” Double Cab <> 4wd, Extra Clean <> on 2040-cars

Auto blog

Former NHTSA chief may lead automaker-backed Takata investigation

An automaker-led effort may see the former head of the National Highway Traffic Safety Administration take on the probe into the Takata airbag inflator disaster. A coalition of at least ten automakers is in talks with former NHTSA administrator David Kelly, with unnamed sources familiar with the discussions telling The Wall Street Journal he is "among those we are considering to coordinate" the investigation.The Detroit News, meanwhile, is reporting he could be hired "in the coming days." Takata, the Japanese seatbelt and airbag manufacturer, has been the center of a defect scandal since last year. Takata is under fire for air bag inflators that can explode, shooting out metal and plastic pieces. At least five deaths and dozens of injuries have been linked to the problem worldwide. Earlier this year, Honda Motor Co., the automaker with the biggest exposure to the defective Takata air bags, was fined $70 million in the U.S. for not reporting to regulators some 1,729 complaints that its vehicles caused deaths and injuries, and for not reporting warranty claims. It was the largest civil penalty levied against an automaker. Should he take the role, Kelly would be at the fore of an investigation being assembled by an alliance of ten automakers, which includes the Detroit Three and Honda. Toyota first suggested a joint investigation back in December, The Journal reports. Kelly's goals, meanwhile, will be many. The Detroit News reports that questions abound regarding not only the recalled airbag inflators and the conditions that cause them to fail, but the whether the replacement units will have similar problems in the future. The automaker committee is far from the only one analyzing the airbag issue. Takata has assembled its own panel, led by former Secretary of Transportation Samuel Skinner, while NHTSA's deputy administrator, David Friedman, has brought in an outside engineering firm to investigate the inflators, The Detroit News reports. Separately, on Friday Takata Corp., the Japanese seatbelt and air-bag maker at the center of a defect scandal, is expecting more red ink for the fiscal year through March. It is projecting a 31 billion yen ($264 million) loss, worse than the previous forecast for a 25 billion yen ($214 million) loss, despite higher sales expected for the fiscal year. Ten automakers have recalled about 12 million vehicles in the U.S. and about 19 million globally for problems with the air bags.

Japan plans real-world diesel emissions test after companies fail

Japan's transport ministry plans to start real-world diesel emissions tests after an experiment found four models from Toyota, Nissan, and Mitsubishi that produced more nitrogen oxide (NOx) emissions than the nation's rules allow, according to The Japan Times. Regulators there usually only perform emissions checks in the lab. The VW diesel scandal has everyone double-checking their figures. Diesel versions of the Toyota Hiace van, Land Cruiser Prado, and Nissan X-Trail produced up to 10 times more NOx than allowed. The Mitsubishi Delica D:5 was up to five times over the limit, The Wall Street Journal reports. There was no evidence of defeat devices in the vehicles. Mazda performed well in the experiment, though. The CX-5 passed with nearly the same results on the road and in the lab. The Demio, better known as the Mazda2, did nearly as well with only slighter higher figures in the real world than in the controlled setting. The experimenters theorized the reason for the excessive emissions was that cold weather caused the engines' software to shut off the exhaust gas recirculation to prevent damage, according to the WSJ. However, this behavior also increased NOx production. Toyota, Nissan, and Mitsubishi don't have to worry about punishment from the transport ministry because this check was just an experiment. Their models already passed the mandated lab tests, which was the only requirement, according to The Japan Times. As governments begin greater real-world emissions tests, the results suggests diesels aren't very clean. A recent check in France found models from Ford, Renault, and Mercedes-Benz that didn't perform up to the standards. Regulators in India conducted similar evaluations and ordered VW to recall over 300,000 vehicles. Related Video:

Toyota to recall 185k cars globally, including Yaris

Toyota has announced it is recalling a total of 185,000 vehicles worldwide for a power steering issue. Yaris and (overseas) Vitz models built between November 2010 and March 2012 could suffer a short circuit in their power steering control module if water gets inside. Should that happen, the power steering could fail, increasing effort when turning. The recall also includes the Verso-S and Ractis built from August 2010 to August 2011. The recall covers 130,000 vehicles in Japan and around 22,450 in Europe.
Only 74 units are being recalled in the United States.
Toyota says if the fault occurs, the vehicle will display the Electronic Power Steering warning light on the dash and a buzzer will sound. The automaker will alert owners by mail and dealers will replace the power steering control module free of charge. You can read the quick press release on the recall below for more information.