2010 Toyota Matrix on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Who sold the most small/midsize pickups in 2012? PickupTrucks.com investigates that, too

PickupTrucks.com has taken another look at the sales of its favorite vehicle bodystyle as part of an ongoing series. According to registration data from R.L. Polk, the Toyota Tacoma easily took the crown as America's best-selling mid-sized pickup, with 133,477 units rolling into new homes in 2012. For comparison, the second-place Nissan Frontier only saw 50,566 registrations.
We feel compelled to point out that before Ford pulled the plug on its ancient Ranger, the company was moving some 75,000 units per year. That number had shriveled to 15,662 by 2012, which was still enough to surpass the Honda Ridgeline. Interestingly enough, one person brought home a brand-new Hummer H3T as well. But mid-sized trucks represent only a fraction of total pickup sales. Dealers sold a total of 241,471 midsizers last year compared to 988,326 half-tons.
That segment was dominated by General Motors with 533,814 sales followed by Ford at 478,204. Ram Trucks trailed behind in third with 241,204 units with Toyota close behind at 229,769. Nissan, meanwhile, remains a distant fifth. Head over to PickupTrucks.com for a closer look at the breakdown in each segment.

Toyota, Lexus will offer low-cost automated braking system

First, a technology gets better, then it gets a lot better, then it gets less expensive, then it gets a lot less expensive. Advanced driver safety and convenience systems are about to make that last step thanks to Toyota. Centered around a pre-collision braking system, there will be three suites of driver aids known as Toyota Safety Sense C (TSS C) for compact cars, Toyota Safety Sense P (TSS P) for midsized and premium cars, and Lexus Safety System+ (LSS+) for the luxury brand. TSS C pairs a camera with laser radar to provide a pre-collision system that prompts the driver to brake if it detects an impending accident, and can supply additional braking force and automatically brake between seven and fifty miles per hour. There are also Lane Departure Alert and Automatic High Beam. TSS P pairs a camera with more precise millimeter-wave radar. Starting with the three functions in TSS C, it adds pedestrian pre-collision capability and adaptive cruise control. This one will be available first, coming on the new RAV4 Hybrid and Avalon. TSS - either C or P - will expand to three more vehicles by the end of the year. The wallop is in the price: TSS C will be a $300 option, TSS P will cost $500. Compare the Ford Fusion SE, for instance - it's Driver Assistance Package comes with Lane Departure Warning, Automatic High Beams, it has Lane Keep Assist, Blind Spot and Cross Traffic Detection that neither TSS has, but doesn't have any autonomous braking feature. It costs $1,200, but requires you to add the Technology and Luxury Packages for a total price of $3,165. If you want Autonomous Cruise Control, that's another $995, for $4,160 in total. Instead of $300 or $500 on the Toyota. Lexus' LSS+ will come first on the new RX then spread to four more models by the end of this year, and cost between $500 and $635 to add as an option. It also uses a camera and millimeter-wave radar for its vehicle and pedestrian pre-collision system, lane departure warning and lane keep assist, automatic high beam, and auto cruise control. The similar package on a BMW X5, with no pedestrian component, is $1,200. Toyota says both safety suites will eventually be on "nearly all" of it products and all trim levels by the end of 2017.