2012 Toyota Highlander Limited Sport Utility 4-door 3.5l on 2040-cars

Auto blog

NHTSA investigating 561k Toyota Prius hybrids for possible steering shaft defect

The Detroit News is reporting that the National Highway Traffic Safety Administration will investigate some 561,000 Toyota Prius models for potentially defective steering shafts. The affected hybrid models are from the 2004-2009 model years. The story indicates that NHTSA is weighing whether or not to grant a defect petition, which claims that Toyota incorrectly assembled the hatchback's steering linkage.
As of this writing, there is no recall. However, a recall based on the Prius steering shaft would be the third related to steering issues for the model since 2006. Seven years ago, Toyota recalled 170K Prius models for potential cracking of the intermediate shafts, and in November of 2012, the automaker recalled 670K units to replace the steering shaft extension assembly.
We'll be monitoring NHTSA's signals to see if this investigation turns into a full-fledged recall. For now, stay tuned.

Audi S4 drivers are the most accident-prone, insurance report says

Culling data from more than 4.6 million automobile insurance applications, researchers at the Insurify insurance comparison marketplace picked a winner — or more to the point, a loser — in its determination of the car model with the most accidents so far in 2023: the Audi S4. Why does the sporty, luxury-class German sedan rank so high (or so low)? The organization found that S4 drivers, piloting a car with almost 350 horsepower, are among those who collect the most speeding tickets, and that they get into accidents at a rate 54 percent higher than the national average. If the S4 isnÂ’t a surprise with an at-fault accident rate of 11.7 percent, consider the “family friendly” brand that appears three times on the Insurity list: Subaru. It is represented by three models, including the turbocharged WRX and XV Crosstrek, and at the better-performing bottom of the list, the Subaru Impreza, with an accident rate of 10.3 percent.  In 2023, 7.6 percent of U.S. drivers were involved in at least one at-fault accident in the prior seven years. For drivers of cars on this list, the average at-fault accident rate was 10.5 percent, meaning these drivers are 1.4 times as likely to have an at-fault accident on record. According to its statement, the Insurity data science team explored key safety features, driver behavior, and Insurance Institute for Highway Safety (IIHS) evaluations to pinpoint possible reasons behind these carsÂ’ high accident rates. Following is the list, counting down to the models with most reported accidents: 10. Subaru Impreza (percentage of drivers with a prior at-fault accident on record: 10.3 percent; MSRP base model): $19,795) 9. Kia Niro (percentage of drivers with a prior at-fault accident on record: 10.4 percent; MSRP base model): $26,590) 8. Chevrolet Silverado LD (percentage of drivers with a prior at-fault accident on record: 10.4%, MSRP base model): $34,500) 7. Subaru XV Crosstrek (percentage of drivers with a prior at-fault accident on record: 10.5 percent, MSRP 6. Subaru WRX.(percentage of drivers with a prior at-fault accident on record: 10.7% MSRP base model): $29,605) 5. Toyota GR86 (percentage of drivers with a prior at-fault accident on record: 10.8 percent MSRP base model): $29,900) 4. Hyundai Veloster N (percentage of drivers with a prior at-fault accident on record: 10.9 percent; MSRP base model): $32,500) 3.

Toyota R&D shows off free piston engine linear generator for future EVs

We often hear how an electric vehicle powertrain architecture allows vehicle designers much more freedom than a traditional ICE powertrain does. With differently shaped battery modules and small electric motors, there are lots of way to put the pieces together. With today's plug-in hybrid technology, engineers still need to put a decent-sized ICE somewhere, but new technology from Toyota could free up the gas-electric vehicle designers of the future. Presented at the recent SAE World Congress in Detroit, the idea from Toyota Central R&D Labs Inc. and involves what is called a Free Piston Engine Linear Generator (FPEG). Think of it as a sort of one-cylinder, two-stroke mini-engine that can work either as a generator (thank to magnets and a linear coil) or to directly drive a vehicle. The current prototype is a 10-kW unit that Toyota say would provide enough power to get a B- or C-segment electric vehicle up to highway speeds (75 miles per hour) when paired up to offer 20 kW. Pairing the FPEGs is also important to minimize vibrations. One system tested by Toyota had a 42 percent thermal efficiency, but the engineers are working to improve the overall efficiency even further. You can watch an animated video of the piston in action here (click on "Outline") and see the SAE papers here and here. More technical details are available at Green Car Congress. News Source: Toyota Labs via Green Car CongressTip: Thanks, Joe V. Green Misc. Auto Shows Toyota Technology Emerging Technologies Electric generator