2008 Toyota Avalon Xls Loaded Well-maintained With Transferable Warranty To 125k on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

CARB uses tricked-out RAV4 EV to measure air pollution in California

The old-school Toyota RAV4 EV you see above is the California Air Resources Board's version of a non-participant observer. The all-electric vehicle cruises around the state measuring airborne pollution. Since it's powered by batteries, there are no tailpipe emissions created as CARB tries to get a handle on how dirty the roadway air is. The problem, CARB says, is that it is difficult to measure air pollution levels, "during calm conditions at night and in the early morning." There are over 250 stationary air monitoring sites in California today, but the Board wanted a way to expand where and when it can test for things like ultrafine particles, carbon dioxide and nox. The original plan for the Mobile Monitoring Platform – as the RAV4 EV is officially called – was to "Investigate Spatial, Diurnal and Seasonal Pollution Gradients" on California's highways and ports. The RAV4 EV was originally expected to cost $280,000 (see pages 11-12 in this PDF from 2009), but a new report in the Modesto Bee says it had a total of $300,000 just in monitoring equipment. Michael Benjamin, CARB's chief of air monitoring, told the Bee that the MMP, "paints a thorough picture about what air quality is in any given community." More importantly, the stationary and mobile testing equipment can tell CARB when and where the air is getting cleaner. Which is the whole point, after all.

Consumer Reports calls on Toyota to recall older Camry Hybrid models

Consumer Reports is calling on Toyota to issue an official recall of 178,000 Camry Hybrid sedans from model years 2007 to 2011, claiming that a pair of issues affecting the brakes are so dire they demand a more official action than what the company has undertaken so far.
The first issue, as CR tells it, relates to a clog in the brake-fluid reservoir filter, which if left untreated could lead to a number of dashboard warning lights. The "front brake assist could be temporarily lost," too, according to Toyota's own notice to dealers and owners of affected models. The company has issued a "service campaign" that will fit a new brake-fluid reservoir free of charge to any affected model brought to a dealer by June 30, 2017.
The other issue plaguing the fuel-sipping Camrys is being treated via a warranty extension, and focuses on the ABS brake actuator, a particularly expensive (both in terms of parts, at $1,000, and labor, around $3,000) item that is necessary for the anti-lock braking to function. There's also a related issue with the brake pedal's "stroke sensor," which like the actuator can lead to a very difficult-to-depress brake pedal. The warranty extension increases the coverage of the actuator to 10 years or 150,000 miles (whichever comes first).