2007 Toyota Tacoma Access Cab on 2040-cars

Auto blog

NHTSA investigating 561k Toyota Prius hybrids for possible steering shaft defect

The Detroit News is reporting that the National Highway Traffic Safety Administration will investigate some 561,000 Toyota Prius models for potentially defective steering shafts. The affected hybrid models are from the 2004-2009 model years. The story indicates that NHTSA is weighing whether or not to grant a defect petition, which claims that Toyota incorrectly assembled the hatchback's steering linkage.
As of this writing, there is no recall. However, a recall based on the Prius steering shaft would be the third related to steering issues for the model since 2006. Seven years ago, Toyota recalled 170K Prius models for potential cracking of the intermediate shafts, and in November of 2012, the automaker recalled 670K units to replace the steering shaft extension assembly.
We'll be monitoring NHTSA's signals to see if this investigation turns into a full-fledged recall. For now, stay tuned.

Toyota Recalling 1.67 Million Vehicles Worldwide

UPDATE: Toyota is now announcing specifically which models are covered under its fuel pipe recall in the US. The company is repairing about 423,000 Lexus models that include the 2007-2010 LS, 2006-2011 GS, 2006-2011 IS, 2010 IS C and 2008-2010 IS-F. The automaker says that it isn't aware of any fires, crashes, injuries or fatalities caused by this problem. According to Toyota, the recall is because it's possible for the fuel delivery pipes and the fuel pressure sensor to form a bad seal with the gasket between them because of a protective coating protecting against corrosion on the pipes. It's possible for this to eventually cause a fuel leak, and obviously in a hot engine bay that's a potential fire risk. To fix the problem, dealers will replace the gasket and repair the gasket seating surface between the fuel delivery pipe and the fuel pressure sensor. The company will begin notifying owners soon. You can find the official press release, below. Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected. The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters. The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case. Finally, Toyota is recalling 190,000 Corolla Rumion and Auris models in Japan for a faulty evaporative emission control unit. Autoblog is in contact with Toyota, and we'll update this story as soon as we know more about its affect on the US market.

Toyota mints 10-millionth vehicle in Kentucky

In 26 years, from 1988 up to now, the Toyota Motor Manufacturing Kentucky plant in Georgetown has built ten million vehicles - nearly enough for every citizen of Seoul, Korea or the nation of Hungary. The first car to roll off the line back when the claymation California Raisins were singing old Marvin Gaye hits and everybody wanted to know Who Framed Roger Rabbit? was a white Camry. The ten-millionth car to roll off the line among the Avalons and Venzas also produced there: a white Camry Hybrid.
Toyota has put $5.9 billion into the site since its inception, employment is up to 7,000 associates and will grow when Lexus ES350 assembly begins next year. Whereas car number one is a showpiece for the ages, one of the automaker's current associates will get to win the ten-millionth car in a blind drawing to be held this summer.
There's a press release below with more information on the impressive milestone.