2011 Toyota Sienna Le 8-passenger Rear Cam 3rd Row 49k Texas Direct Auto on 2040-cars

Auto blog

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

Recharge Wrap-up: Honda FCV Concept comes to Detroit, Toyota seeks young green energy fellows

Honda will bring its FCV Concept to the 2015 North American International Auto Show in Detroit in January. The hydrogen-powered concept made its Japanese debut in November, and will now make its way to North America for the first time. The FCV concept improves upon the design of the FCX Clarity with a more striking appearance and roomier interior. Its smaller powertrain packaging means more space for people, and the FCV Concept seats five passengers. Honda also expects the next-generation fuel-cell car, which is scheduled to go on sale in Japan in March 2016, to cost less and have a range of over 300 miles. Read more in the press release below. The Mercedes-Benz B-Class Electric Drive has been awarded an environmental certificate from the TUV Sud technical inspection authority. The certificate is based not just on the vehicle's operation, but the entire lifecycle of the car, including production and recycling. The B-Class Electric Drive produces 24 percent less CO2 over its lifecycle than the Mercedes-Benz B180 when using the EU electricity mix, and 64 percent less when powered by hydroelectricity. Mercedes credits not just the use of electricity, but also the car's energy management system - such as its radar-based regenerative braking - for its carbon reductions. Read more in the press release below. Scania will test a wirelessly charged plug-in hybrid bus in Sweden. Beginning in June 2016, the bus will be put to daily use in Sodertalje. One of its stops will have a wireless charging station where the bus will recharge for six to seven minutes before continuing on its route again. The charger is located under the road surface and the bus positions itself above it to charge inductively. About $1.3 million will come from the Swedish Energy Agency to fund the test project, which could save up to 90 percent of fuel costs. If expanded to a fleet of 2,000 buses, it could save up to 13 million gallons of fuel each year. Read more at Green Car Congress, and in the press release below. Sandia National Laboratories and Linde are teaming up to expand hydrogen fueling infrastructure. The two groups have signed an agreement to research and develop new hydrogen stations, as well as ways to make fuel cell vehicles more desirable for consumers. They are looking at ways to incorporate hydrogen into existing fuel stations where possible, and make sure that it is able to be done safely.

Suzuki and Daihatsu join Toyota electric vehicle venture

TOKYO — Suzuki Motor Corp and Daihatsu are joining a commercial electric vehicle coalition led by Toyota Motor Corp, the carmakers announced on Wednesday, helping the Japanese alliance expand its focus from trucks to smaller cars. The two automakers will each acquire a 10% stake in the joint venture, on par with Isuzu Motors and Hino Motors, while Toyota will hold a 60% stake, they said. "With Suzuki and Daihatsu joining the project and working together, we'll be able to expand our circle of cooperation to not only cover commercial vehicles but also mini vehicles," said Toyota President Akio Toyoda. "With this expansion, I believe that we'll be able to take one step closer to a better mobility society," Toyoda said. The move comes as Japanese automakers face growing competition from tech giants and other rivals making electric and driverless cars. Toyota, Isuzu and Hino launched the Commercial Japan Partnership Technologies Corporation in April to bolster their competitive edge in connected, commercial vehicles. Daihatsu's president Soichiro Okudaira said joining the pact and introducing connected, mini-commercial vehicles would allow data sharing, a major benefit for companies to provide better services to customers and improve logistics efficiency. (Reporting by Eimi Yamamitsu; Writing by Ritsuko Ando; Editing by Louise Heavens) Related Video: Green Suzuki Toyota Daihatsu Electric Akio Toyoda