2022 Toyota Rav4 Xle on 2040-cars

Auto blog

Toyota to ramp up Tacoma production in Mexico by 41%

The Toyota Tacoma may be getting on in age, but that isn't stopping the Japanese manufacturer from ramping up production at the pickup's Baja California factory. The Mexican plant will soon be home to another 300 jobs as it increases total capacity by 41 percent. The increase is slated for April 2015.
The move is a curious one, considering the Tacoma's age and the fact that General Motors is preparing what, on the surface, appear to be two very competent challengers. The factory increase could be in preparation for the 2016 Taco (spy photos shown above), which is expected to represent a significant overhaul of the long-serving truck.
Toyota's decision to increase capacity could also be due to the factory building freeze implemented by President Akio Toyoda, according to Automotive News. Toyoda put a hold on new factories until 2016, asking executives to squeeze as much production as possible out of remaining factories before bringing any additional facilities online.

NHTSA opens safety investigations into Toyota, GM and Honda crossovers

The National Highway Traffic Safety Administration is evidently keeping itself very busy these days, as the federal agency has just announced it is launching or renewing investigations into Toyota, Honda and General Motors crossovers.
2006-2008 model year Toyota RAV4 crossovers are under review for allegations of rear tie-rod rust which can result in failure. NHTSA also said it is probing some 35 complaints about 2005 Honda Pilot models with inappropriate activation of the vehicles' stability control system. The alleged malfunction can cause the vehicles to slow down or stop in bad unsafe situations. At the moment, NHTSA is reviewing a petition regarding the Pilot issue, a move that will determine whether it needs to open a full-blown investigation.
In addition, Saturn Outlook and GMC Acadia three-row crossovers built in 2007-2009 are getting looked at for "loss of low beam headlamp" function. One complainant said the wiring in his Outlook overheated and melted. NHTSA says it has received 415 complaints about the problem and a GM spokesman confirmed that the automaker already started a "Customer Satisfaction Program" in December to address the issue.

Toyota issues multiple recalls for 6.4 million vehicles worldwide

It looks like 2014 may go down as the year of recalls. We were already at a record pace, and now it seems Toyota is recalling 6.39 million vehicles worldwide, including about 30 of its models for a variety of problems. None of the faults have caused any injuries or fatalities, but there have been two reports of fires caused by a defective engine starter motor.
Toyota's numbers show 1.772 million vehicles being recalled in the US, but that includes some overlap because the Yaris is being repaired for multiple faults. According to The Detroit News, there are 2.36 million affected models in all of north North America, 1.09 million in Japan and 810,000 in Europe, plus smaller numbers in other regions.
Among the vehicles recalled in the US are 1.3 million units of the 2009-2010 Corolla, Matrix and Tacoma, the 2008-2010 Highlander, the 2006-2008 Rav4 and 2006-2010 Yaris. The problem is that the driver's airbag module is attached via a spiral electrical cable. The connections on the cable can be damaged when the steering wheel is turned, which deactivates the airbag and causes the airbag warning light to come on. Toyota is replacing the cable with an improved part, but it's still making preparations to begin the repair. The company is sending affected owners notifications in the mail. According to The Detroit News, an unspecified number of Pontiac Vibe vehicles are also included in this recall because it shares the part with the Matrix.