2009 Toyota Limited With Extra Value Package on 2040-cars

Auto blog

Toyota Expands Airbag Recall To 2.2 Million Vehicles Worldwide

Was your Toyota inspected under the company's recall campaign for faulty airbag inflators last year? You might have another trip ahead to have it repaired again. The automotive giant says that it found "the involved serial numbers provided by the supplier were incomplete, and did not include all of the potentially involved inflators," according to its official announcement. That means more replacements are needed. Toyota's April 2013 inflator recall covered the Corolla, Matrix and Tundra from the 2003 and 2004 model years, the Sequoia from 2002 to 2004 and the Lexus SC 430 from 2002 to 2004. At the time, the company said it would need to inspect about 510,000 vehicles in the US but only expected to replace around 170,000 inflators. However, the latest announcement increases that figure to about 766,300 vehicles in the US. Toyota spokesperson Cindy Knight told Autoblog that the new amount is the combination of owners who need to have their vehicle looked at again and those who didn't come in for the initial recall. The company learned about the problem when Takata, the supplier, provided it with an improved list of the faulty part's serial numbers. According to The Detroit Free Press, the latest recall affects about 2.27 million vehicles from them worldwide. Knight said owners would receive notification of the problem around the end of the month but repairs would come in phases because the automaker doesn't have all of the necessary parts at the moment. The original problem occurred because the front passenger airbag inflator from Takata could have an improper propellant that could cause it to burst in an accident and not allow the airbag to deploy properly. Toyota inspected all the vehicles listed but only changed the inflators with specific serial numbers. Now, it's replacing them all. This wasn't just a problem for Toyota, though. Honda, Nissan and Mazda also used the faulty inflators and issued recalls at the same time. Autoblog has contacted the other Japanese automakers about whether similar campaigns are necessary for them. We will update this story, if we hear back from them. Scroll down to read Toyota's announcement. UPDATE: Honda spokesperson Jessica Howell sent along the following statement: Honda is aware that Toyota recently announced a recall of front passenger's airbag inflators. Honda is not aware of any incidents in our vehicles related to Toyota's action. We are currently investigating the potential implications to Honda vehicles.

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

Toyota responds to video of Highlander ramming house [w/video]

There are, as they say, two sides to every story, so after we posted a video on Monday showing what an owner claimed to be a case of unintended acceleration causing her Toyota Highlander to crash into a house twice, Toyota reached out to us revealing some additional information about the incident.
Following this crash, which took place back in November, Toyota had this Highlander inspected and pulled data from its Event Data Recorder (EDR), or Black Box as we've come to call it. Not only was this the first time we've seen a claim of unintended acceleration like this caught on video, but now, also a first, we have actual data showing what the vehicle itself recorded during this frightening ordeal.
Brian Lyons, Toyota Communications Manager for Safety and Quality, first gave us some information about the Highlander in question, including the fact that it was a 2012 model. The 2012 Highlander came from the factory with a brake override system, meaning it was not part of the company's initiative in 2010 to add the system to all 2011 models. Also, after looking at the data from the EDR, he said - as many of you pointed out in the comments for the previous post - that the "brake pedal was never touched." In the video, you can see that the crossover's brake lights never come on, and the EDR's data backs this up.