2013 Toyota Prius V Two on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Toyota vows to fix poor Camry crash test result that irked Consumer Reports

Many Toyota vehicles haven't been performing well in the Insurance Institute for Highway Safety's (IIHS) small overlap frontal crash test, and the Camry is one of them. The 2012 and 2013 Camry both received "Poor" ratings, IIHS' lowest rating, in the test, which spurred Consumer Reports to take the car off its "Recommended" list. In response to the low ratings in the small overlap frontal test, and in a bid to maintain its best-seller status, Toyota will make changes to the Camry to improve its IIHS safety rating and to enhance its design, The Detroit News reports.
The Camry performed well in the moderate overlap frontal, side, roof strength and head restraints and seats crash tests, receiving "Good" ratings, IIHS' highest rating, in all four tests. That was enough for IIHS to award it a Top Safety Pick rating, just not TSP+.
Bill Fay, head of Toyota's US division, reportedly says, "It's still a five-star car. It still does very well in all the IIHS tests. It did not in [the small overlap frontal crash test], and we're busy making the necessary adjustments so that we can address that."

Toyota confirms all-wheel drive V8 hybrid for TS040 LMP1 car in 2014

The 2014 FIA World Endurance Championship is gearing up to be one of the most exciting seasons of endurance racing in recent memory. All of the factory-entered LMP1 class cars are using hybrid powertrains, and Porsche is returning to the top class of the sport after a 16-year absence. Don't count out Toyota, though. The team has just revealed the first official details about its 2014 TS040 LMP1 car, and it has a big surprise - all-wheel drive.
The TS040 will follow Audi's lead and will use a combination motor and generator to power the front wheels. The system will generate power under braking and will use it up when accelerating to give a boost in traction over last year's rear-wheel-drive Toyota TS030. Toyota will stick with a gasoline-fueled, naturally aspirated 3.4-liter V8 to feed the rear wheels and will take on Audi's diesel, turbocharged 3.7-liter V6 and Porsche's gasoline-fueled, turbo 2.0-liter four-cylinder.
Sadly, there are no real pictures of the TS040 yet. Toyota is holding off on unveiling the car until the end of March at the WEC test at the Paul Ricard circuit, and the racing season doesn't begin until April 20 with the 6 Hours of Silverstone. You can read the whole press release about the TS040 below.