2011 Toyota Fj Cruiser Base on 2040-cars

Auto blog

Mazda's new Mexican plant capacity rises to 230,000

After the turmoil of last year, 2013 is getting off to a much better start for Mazda. The company has issued a release indicating that the forthcoming plant in Salamanca, Mexico has had its production capacity raised even though it isn't scheduled to go online until March 2014. The original plans called for a 140,000-unit capacity, 90,000 of that allotted for the Mazda2 and Mazda3, the remaining 50,000 for a small car Mazda would build for Toyota that would be based on the Mazda2. The new plans call for raising that by 90,000 units to a total of 230,000 units within two years, by the end of March 2016, and it looks like it will all go toward Mazda production to satisfy growing demand for Skyactiv vehciles. The Mexican plant's opening will be the return of Mazda manufacturing to North America, after Mazda6 production was moved back to Japan last year.
More good news for the company is that it projects 10 billion yen ($114 million) in net income for the financial year that will end in March. That would be a welcome turnaround from the 100-billion-yen loss in the previous financial year, part of a series of three annual losses in a four-year span.
You'll find the press release with the factory update below.

Toyota Yaris Hybrid-R is road-going version of brand's racing technology [w/video]

Did you know that the Yaris is Toyota's best-selling vehicle in Europe? That may help explain to us Americans why the car that's lowest on the company's totem poll here in the US got turned into an all-wheel-drive hybrid track monster for the 2013 Frankfurt Monster Show.
Called the Toyota Yaris Hybrid-R, this three-door pocket rocket isn't just a hybrid making a lot of horsepower - it incorporates technology from Toyota's TS030 Hybrid racecar that competes in the FIA World Endurance Championship series, including the 24 Hours of Le Mans. The Yaris Hybrid-R packs a 300-horsepower, turbocharged, 1.6-liter four-cylinder engine under its hood, which should be enough for most speed freaks, but Toyota pairs it with two 60-hp electric motors at each rear wheel (the same ones used in the production Yaris Hybrid that's sold in Europe). That makes total system output an insane-for-this-size 420 hybrid horsies.
But that's not all, as the Yaris Hybrid-R forgoes the traditional battery pack below the rear seats in favor of a supercapacitor, which can both hold more energy and has a much faster power charge/discharge speed than traditional batteries. Paired with the supercapacitor is a third 60-hp electric motor/generator positioned between the engine and six-speed sequential transmission. Its job is to feed the super capacitor energy during deceleration and direct its power to the rear electric motors when more grip and oomph is needed.

Toyota urges owners of old Corolla, Matrix and RAV4 models to park them until airbags are replaced

DETROIT — Toyota and General Motors are telling the owners of about 61,000 older Corolla, RAV4, Matrix/ Pontiac Vibe models to stop driving them because their Takata airbag inflators are at risk of exploding and hurling shrapnel. The urgent warning Monday covers: Certain Corolla compact cars and Matrix hatchbacks from the 2003 and 2004 model years. RAV4 small SUVs from 2004 and 2005. Also covered are about 11,000 Pontiac Vibes from 2003 and 2004, which are essentially the same as the Matrix and were made at the same California factory. Most of the vehicles are in the U.S. “If the airbag deploys, a part inside is more likely to explode and shoot sharp metal fragments, which could cause serious injury or death to the driver or passengers,” Toyota said in a statement. Owners can go to nhtsa.gov/recalls and enter their 17-digit vehicle identification number to see if their cars are affected. If you're not the original owner of the vehicle, the manufacturer's recall letter might not reach you, so be sure to do the VIN check. The recalled RAV4s have Takata driver's airbags while the Corolla and Matrix models have them on the passenger side. The Corolla and Matrix also are under a separate recall because their airbags can be deployed without a crash, the company said. Both companies said owners should contact a local dealer instead of driving the cars in for repairs. Dealers will provide options such as mobile repair, towing the car to a dealer, or vehicle pickup and delivery. Takata used volatile ammonium nitrate to create a small explosion to inflate airbags in a crash. But the chemical propellant can deteriorate over time when exposed to high temperatures and humidity. It can explode with too much force, blowing apart a metal canister and spewing shrapnel. At least 26 people have been killed in the U.S. by Takata inflators since May 2009, and at least 30 have died worldwide including people in Malaysia and Australia. In addition, about 400 people have been injured. The exploding airbags sent Takata of Japan into bankruptcy. The potential for a dangerous malfunction led to the largest series of auto recalls in U.S. history. About 100 million inflators were recalled worldwide. Recalls Pontiac Toyota Takata airbag recall