Auto blog

10 automakers shack up in Detroit hotel to talk Takata airbags

Since Takata has decided not to take the lead concerning potential issues with its airbag inflators, the automakers have. Perhaps that's unsurprising, since it's the automakers, not Takata, that will take a beating on the dealership floor if consumers decide its models are a health hazards. The Detroit News reports that Toyota, Honda, General Motors, Ford, Chrysler, Mazda, BMW, Nissan, Mitsubishi and Subaru met in a hotel conference room near the Detroit Metropolitan Airport last week to sort out a way to understand the technical issues involved. So far, faulty airbag inflators have been ruled the cause of five deaths and 50 injuries around the world, but neither Takata nor investigators understands exactly why the inflators are malfunctioning. The National Highway Traffic Safety Administration recently asked Takata to issue a national recall, Takata declined, citing a minuscule failure rate and the fact that it's still investigating the issue. Toyota and Honda then made an industry-wide appeal for "a coordinated, comprehensive testing program" that would pinpoint the problem inflators and get them replaced, and that's what the Detroit meeting was about. Numerous issues, however, will make this a long row to hoe: simply getting the parts to replace the nearly 20 million inflators in cars recalled around the world so far - even working with other suppliers - will take a years, but more importantly, no one knows if the replacement inflators currently being installed will suffer the same issue. Answers will hopefully come quickly with Takata, the ten automakers and NHTSA all independently investigating the problem.

Thanks to smaller engines, vehicle dependability falls for first time in 16 years

As automakers have made engines smaller and smaller to improve fuel economy, problems in those vehicles have gotten bigger and bigger. That's the synopsis of a J.D. Power vehicle-dependability study, which found that dependability dropped for the first time in 16 years, largely because the proliferation of four-cylinder engines is causing the vehicles to be less reliable. Specifically, the number of problems per 100 vehicles (or what J.D. Power calls PP100) during the past 12 months for 2011 model-year vehicles rose six percent from the year-earlier figures for 2010 model-year cars. Singling out four-cylinder vehicles revealed about a 10-percent increase in problems during the past year. This issues largely related to engine hesitation, rough transmission shifting and lack of power, signaling the inability of vehicle makers to iron out some of the problems in their smaller engines as they strove for better fuel economy. Six- and five-cylinder engines proved far more reliable. Among car brands, BMW's Mini sub-brand came out as least reliable, with 185 problems per 100 vehicles during the past year. Toyota's Lexus badge was easily the most reliable, with just 68 problems per 100 vehicles. Coming in second place was Mercedes-Benz. The overall average was 133. Check out J.D. Power's press release below. J.D. Power Reports: Increased Engine and Transmission Problems Contribute to Decline in Vehicle Dependability for The First Time in More Than 15 Years General Motors Company Receives Eight Segment Awards, While Toyota Motor Corporation Garners Seven and Honda Motor Company Earns Six WESTLAKE VILLAGE, Calif.: o Owners of 3-year-old vehicles (2011 model year) report more problems than did owners of 3-year-old vehicles last year, according to the J.D. Power 2014 U.S. Vehicle Dependability StudySM (VDS) released today. The study, now in its 25th year, examines problems experienced during the past 12 months by original owners of 2011 model-year vehicles. Overall dependability is determined by the number of problems experienced per 100 vehicles (PP100), with a lower score reflecting higher quality. The study finds that overall vehicle dependability averages 133 PP100, a 6 percent increase in problems from 126 PP100 in 2013. This marks the first time since the 1998 study that the average number of problems has increased. "Until this year, we have seen a continual improvement in vehicle dependability," said David Sargent, vice president of global automotive at J.D.

Toyota's Bob Carter says far fewer stations needed in shift from gas to hydrogen

Toyota's Bob Carter has been talking about green cars for years, but it's only been recently that his comments have really caught widespread attention thanks to his disparaging remarks about electric vehicle supporters like Elon Musk and Carlos Ghosn and optimism about hydrogen. Speaking at the opening of the Chicago Auto Show this morning, Carter said that Toyota has claimed the "pole position on CAFE," thanks to its deep hybrid bench. The company's green car cred will continue to grow because of its upcoming hydrogen fuel cell car, due out next year. Carter is relentlessly optimistic: "I truly believe fuel cells will fundamentally change how we feel about transportation," he said. The reason, Carter said, is that a hydrogen infrastructure will be easier to install than people think. He referenced a study conducted by the University of California (which we've heard about before) that found that California would only need 68 hydrogen stations to refuel the roughly 10,000 H2 vehicles that Toyota hopes to sell in by 2016 or so. That's a lot more than the nine that exist today, but the state has already approved funding for 20 new stations by 2015 and then up to 100 by 2024. Then he said this: "If every vehicle in California ran on hydrogen, we could meet refueling logistics with only 15 percent of the nearly 10,000 gasoline stations currently operating in the state." "We could meet refueling logistics with only 15 percent of gasoline stations currently operating in CA" - Bob Carter This made us wonder: if the refueling time and range are roughly equivalent between hydrogen and gasoline – Toyota's hydrogen car is supposed to be able to go 300 miles on a five-minute fill-up - then why has the market decided that there should be 10,000 gas stations in California and why would 1,500 be sufficient for hydrogen? "If the locations are optimized," he said, "we don't need 10,000 stations." For example, at major intersections, instead of three gas stations, you'd really just need a single hydrogen one. "There are a lot of questions about the infrastructure, but it's coming. ... It's a hurdle that we've got to climb but it's not as steep as some may imagine." Toyota's Mike Michaels, the national manager, media and public affairs at Toyota Motor Sales, then stepped in to point out that there are gas stations closing and admitted that there might be too many gas stations in California.