2004 Saturn Ion Red Line Coupe 4-door 2.0l on 2040-cars

Auto blog

Junkyard Gem: 2004 Saturn Vue with manual transmission

GM's Saturn Division has been gone since the final 2010 Auras, Outlooks, Skies, and Vues slunk apologetically out of the showrooms, and I'm doing my best to document the more interesting models from The General's once-revolutionary brand. Some of the later Saturns began life as Opel designs, but the Vue actually was the first vehicle to go on the all-new GM Theta platform; the Opel Antara was thus a Saturn copy, a fact that Saturn fans no doubt trot out when they get shamed by Opel zealots over the Astra. Today's Junkyard Gem is a most unusual Vue, in the sense that its original purchaser was fine with both the base manual transmission and the leather-upholstery upgrade. Sure, the cheapest way to buy a new Vue— which was sold here for the 2002-2007 model years— was to get it with the base transmission: a five-speed manual. You can still buy a new car with a five-on-the-floor manual right now, but only in a handful of cheapmobiles; by the middle 2000s, a tiny-and-ever-shrinking subset of American car shoppers would even consider a three-pedal commuter vehicle. Really, there were only two reasons an American new-car buyer would have considered a non-enthusiast vehicle with a manual transmission in 2004: either an eccentric preference for the good ol' stickshift or just plain penny-pinching. The cheapest possible '04 Vue was the version with four-cylinder 2.2-liter engine, front-wheel-drive, and five-speed manual transmission, and it started at $17,025 (about $26,080 in 2022 dollars). That's what we're looking at here. The optional CVT automatic transmission cost an additional $2,095 ($3,210 today), so it made sense to get the manual if you wanted to save serious money on your Vue. However, this car is loaded to the gunwales with nice equipment upgrades, to the tune of at least the Leather Appointments Package ($755) and the Sports Plus II Package ($1,300) and probably a lot more.  So, a buyer who didn't care about power (so no V6 engine), didn't want all-wheel-drive, liked driving a manual transmission Â… but insisted on power everything and a full-zoot comfy leather interior Â… in a cheap small SUV sold by a fast-fading brand. The conversations with the Saturn salesmen about this thing must have been interesting. Built in Tennessee, sold new in Denver, will be crushed near Pikes Peak.

Saturn Ion steering probe closed by NHTSA

The National Highway Traffic Safety Administration has closed its investigation into faulty electric power steering motors affecting 334,728 Saturn Ions from 2004-2007, because General Motors has issued a recall for them. The group's research found that the part failed at a high rate in the vehicles.
GM recalled over 1.3 million vehicles a few weeks ago, including the Ion, because the power steering could suddenly fail. If broken, the cars could still turn, but it took greater effort. The automaker is also covering 96,324 2003 Ions with a lifetime warranty for their motors, but it's not immediately replacing them.
NHTSA opened its investigation into the motors in September 2011, and it found 4,787 complaints and 30,560 warranty claims that showed failure for the Ion alone. It estimated a complaint rate of 14.3 incidents per 1,000 vehicles and warranty claim rate of 9.1 percent. The investigation also found evidence of 12 crashes caused by loss of steering, two of which resulted in injuries.

Before Chevrolet's Redline, there was the Saturn Red Line

While Chevy rolls out Redline special editions across more of the lineup at this year's Chicago Auto Show, we've been eating some 'member berries and started thinking about the last time GM used the term. Back in 2004, Saturn rolled out Red Line (two words) editions of the Ion and Vue. The lineup was joined by the Sky Red Line in 2007, and the second-generation Vue kept the tradition going in 2008. This was in the heady days of the mid-2000s, before the financial crisis and GM's bankruptcy reorganization that saw the end of Saturn. The press release headline for the 2008 Sky is now cringe-worthy: "Hot-selling Sky helps drive Saturn product renaissance." Performance lineups were the hot new thing, as automakers attempted to cash in on the tuner trend popularized by The Fast and the Furious. Chevy had SS models, Pontiac had GXP, and Saturn had Red Line. Across the Detroit Metro area, Dodge had a slew of SRT models, and Ford's Special Vehicle Team brought us the SVT Lightning pickup, the SVT Focus, and a smattering of hopped-up Mustangs. The performance cred of Red Line models varied from car to car. The Ion Red Line shared the same engine as the original Chevy Cobalt SS, a 205-horsepower supercharged 2.0-liter four-cylinder, 65 hp more than stock. Car and Driver tested one with a 0-to-60-mph time of 6.1 seconds and said the Ion "tears down the wall that has separated enthusiasts from the Saturn brand for so long." The Vue Red Line, meanwhile, came with the same optional Honda-sourced 3.5-liter V6 you could get in the regular Vue, and added a stiffer, lower suspension, bigger wheels with more aggressive rubber, and recalibrated steering assist. When the Vue was redesigned for the 2008 model year, the Vue Red Line was a similar proposition. The engine was now from GM, and up 7 horsepower to 257, but you could get it in both Red Line and XE trim. Aside from the tire and suspension upgrades, Red Line models now came with a unique front fascia and rear exhaust cutouts. The most exciting Red Line, of course, was the high-performance version of the Sky roadster, which shared underpinnings with its Pontiac Solstice twin. This model came with GM's hot 2.0-liter Ecotec Turbo, good for 260 horsepower. The extra power was crucial in covering up the Sky's unfortunate manual gearbox ratios, which left the non-turbo model aching for torque in lower gears. As we all know, Saturn was taken by the grim reaper in 2009 after an attempt to sell the brand to the Penske Group.