2014 Nissan Quest Sl on 2040-cars

Auto blog

2014 Nissan Leaf EVs recalled for missing welds

The Nissan Leaf has been recalled before, for problems with the passenger-side airbags. Early models of the car has also had start-up issues, but those did not lead to a recall. Today, we're learning about another problem with the world's most popular electric vehicle. In April, the National Highway Traffic Safety Administration issued a recall of a small number of 2014 model year Leaf EVs - just 211 units that were made between February 28 and March 12 of this year – and reminded the world about it this morning with a Tweet. The problem, NHTSA says, is that, "the front structural member assembly may be missing welds," and that means that the car's structural integrity could be compromised in a crash. You don't say. Starting in the middle of June, Nissan will look at the vehicles that could be missing welds and offer replacements for free. If you have a potentially affected vehicle, Nissan should be contacting you soon, or you can call the automaker at the number listed below. Report Receipt Date: APR 16, 2014 NHTSA Campaign Number: 14V192000 Component(s): Potential Number of Units Affected: 211 Manufacturer: Nissan North America, Inc. SUMMARY: Nissan North America, Inc. (Nissan) is recalling certain model year 2014 LEAF vehicles manufactured February 28, 2014, through March 12, 2014. The front structural member assembly may be missing welds, which could reduce the structural integrity of the vehicle if the vehicle is involved in a crash. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection," and 305, "Electric-Powered Vehicles: Electrolyte Spillage and Electrical Shock Protection." CONSEQUENCE: Missing welds may effect the vehicle's integrity in the event of a crash, increasing the risk of injury to the vehicle's occupants. REMEDY: Nissan will notify owners, and dealers will inspect to see if any of the welds are missing. Any vehicle missing welds will be replaced, free of charge. The recall is expected to begin by mid-June 2014. Owners may contact Nissan at 1-800-647-7261. NOTES: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

Nissan's Carlos Ghosn taps the brakes on autonomous car progress

"Self-driving cars remain a long way from commercial reality."
Nissan CEO Carlos Ghosn shocked the automotive industry last year when he announced that his company plans to offer consumers an autonomous car by 2020. The automaker even showed off its self-driving Leaf prototype as proof. He was bolder recently with the pronouncement that select markets could have them in 2018, if laws allowed. The boss' optimism appears to be waning, though, and he's now sounding a lot more conservative about the future. While driverless vehicles are still on the way, Ghosn is hedging his bets with a more gradual implementation of several systems.