Se*leather*dvd*4x4!* on 2040-cars

Auto blog

Nissan recalling 841k vehicles overseas for steering wheel trouble

A possible issue with a steering wheel bolt in the Nissan Micra (shown) and Cube from the 2002 to 2006 model years has Nissan recalling roughly 841,000 units on four continents, as well as Oceania and the Middle East. On the affected cars, the bolt may not have been tightened properly, which could lead to a loss of steering in a worst-case scenario. According to Reuters, there haven't been any reports of accidents or injuries due to the fault, however.
The Micras affected were built in the UK and Japan, the Cubes in Japan. Nissan has yet to say when the recall will begin, but when it does, owners can take their cars to dealers for repairs; the bolt with either be tightened or, if necessary, a new steering wheel installed.

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

10 automakers sued over keyless ignitions

Keyless ignition has rapidly proliferated throughout the auto industry to become a fairly normal feature on new cars. It's supposed to offer the convenience of keeping the fob in your pocket and just pressing a button to drive away. However, ten major automakers are now being sued in US District Court over claims that the system is dangerous, Reuters reports. The suit alleges that people are forgetting to shut off the engine, and the lack of an idle timer is the cause for 13 deaths by carbon monoxide poisoning and multiple injuries. The suit currently includes 28 plaintiffs, according to Reuters, but the lawyers are asking for class-action status to potentially add many more. The case goes after a major swath of the industry, including BMW, Daimler, FCA, Ford, General Motors, Honda, Hyundai, Nissan, Toyota, and Volkswagen, plus their related brands like Acura, Infiniti, Mini, and Lexus. In all, over five million vehicles are affected. The assertion here is that people walk away from their vehicle without shutting it off because they believe the engine shuts off automatically. If parked in a garage, carbon monoxide can build up, leading to poisoning. The lawyers claim automakers know this is a problem and also cite 27 complaints to the National Highway Traffic Safety Administration about the issue, according to Reuters. The plaintiffs are asking for an automatic shut-off and damages from the companies. These concerns have come up before, though. Toyota previously faced a lawsuit over a carbon monoxide death after a woman accidentally left her Lexus running. Also earlier this year, GM recalled 64,186 examples of the 2011-2013 Chevrolet Volt because owners weren't shutting them off. The problem resulted in two injuries, and the company released a software update to limit the idling time.