Black Editio Coupe 3.8l Nav Cd Xm Satellite Radio W/xm Navtraffic 11 Speakers on 2040-cars

Auto blog

Nissan expands, shrinks Leaf recall for missing weld points

Chalk this one up to the quirks of the English language. The other day, we had a post on the recall of a small number of 2014 Nissan Leaf EVs that were missing weld spots. The official bulletin from the National Highway Traffic Safety Administration said that "any vehicle missing welds will be replaced, free of charge." We read that as saying that the welds would be replaced, but in fact it's the cars themselves that will be swapped out. NHTSA said that 211 Leafs were potentially involved in this recall, but we heard from Brian Brockman, Nissan's senior manager of corporate communications, that Nissan is actually looking at, "approximately 276" vehicles. More importantly, Brockman clarified that, "If a vehicle is found to be missing the welds, the entire vehicle will be replaced." NHTSA documents on Inside EVs show that Nissan expects just 0.65 percent of those Leafs will need to be replaced. Brockman wouldn't say exactly how many cars Nissan thinks are affected, but 0.65 percent of 276 is just 1.8 vehicles. Brockman did say that, "you'd be correct to say that we expect the number to be very low." Read Nissan's full statement below. Nissan is conducting a Voluntary Recall Campaign on approximately 276 MY2014 LEAF vehicles to inspect the front member assembly welds. Due to an isolated supplier process error that has been corrected, a small number of vehicles within a subset of MY2014 LEAF vehicles manufactured during a two-week period may have front frame member assembly components that were not welded to proper specification. This can affect crash performance. Within the next few weeks, affected LEAF owners will be asked to bring their vehicle to a certified Nissan LEAF dealer for an inspection. If the vehicle is determined to be affected, Nissan will provide owners with a brand new replacement vehicle at no additional cost. A loaner vehicle will be provided during the vehicle exchange process. It is anticipated that only a handful of retailed vehicles are affected by the weld issue and require vehicle replacement. Nissan is committed to a high level of customer service and satisfaction and is working with its dealers to provide an outstanding ownership experience to Nissan LEAF owners.

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

Infiniti's new Design Director is American Alfonso Albaisa

The man responsible for creating the sleek 2010 Nissan Ellure Concept you see above is now the design director for Infiniti. Alfonso Albaisa (shown at right) has been a member of the Nissan design team for 25 years, but was recently promoted to executive design director for the Infiniti brand.
His past roles at Nissan have included design director for Nissan from 2004 to 2007, vice president of Nissan Design Europe from 2007 to 2011, vice president of Nissan Design America in 2011 and, most recently, he held the title of Nissan's global design director. Aside from Ellure, Albaisa was also responsible for designing the 2012 Nissan Xtrem Concept, "key strategic production vehicles soon to be launched" and he's even contributed to a handful of Infiniti designs. Scroll down for the official press release.