1990 Nissan 300zx Turbo Red! on 2040-cars

Auto blog

DC fast charging not as damaging to EV batteries as expected

As convenient as DC fast charging is, there have been lots of warnings that repeated dumping of so many electrons into an electric vehicle's battery pack in such a short time would reduce the battery's life. While everyone agrees that DC fast charging does have some effect on battery life, it may not be as bad as previously expected. Over on SimanaitisSays, Dennis Simanaitis, writes about a recent presentation by Matt Shirk of the Idaho National Laboratory (INL) called DC Fast, Wireless, And Conductive Charging Evaluation Projects (PDF) that describes an ongoing test of four 2012 Nissan Leaf EVs that are being charged in two pairs of two. One pair only recharges from 50-kW DC fast chargers, which the other two sip from 3.3-kW Level 2 chargers exclusively. Otherwise, the cars are operated pretty much the same: climate is automatically set to 72 degrees, are driven on public roads around Phoenix, AZ and have the same set of dedicated drivers is rotated through the four cars. "Degradation depends more on the miles traveled than on the nature of recharging." What's most interesting are the charts on page seven of Shirk's presentation (click the image above to enlarge), which show the energy capacity of each of the four vehicles. When they were new, the four batteries were each tested to measure their energy capacity and given a 0 capacity loss baseline. They were then tested at 10,000, 20,000, 30,000 and 40,000 miles, and at each point, the DC-only EVs had roughly the same amount of battery loss as the Level 2 test subjects. The DC cars did lose a bit more at each test, but only around a 25-percent overall loss after 40k, compared to 23 percent for the Level 2 cars. Simanaitis' takeaway is that, "INL data suggest that the amount of degradation depends more on the miles traveled than on the nature of recharging." The tests are part of the INLs' Advanced Vehicle Testing Activity work and a final report is forthcoming. These initial numbers from IPL do mesh with other research into DC fast charging, though. Mitsubishi said daily fast charging wouldn't really hurt the battery in the i-MiEV and MIT tests of a Fisker Karma battery showed just 10-percent loss over 1,500 rapid charge-discharge cycles.

Honda, Nissan and Mazda recalling 3 million vehicles for airbag inflators

Three million more vehicles can be added to the worldwide tally to be repaired for the faulty airbag inflators supplied by Takata. Honda, Nissan, and Mazda have all issued recalls to replace the bad part, including about 1.2 million of them in North America. NHTSA has been investigating all three companies, plus Chrysler and Toyota, for potentially affected vehicles.
Honda is recalling roughly 1.02 million Civic, CR-V, Odyssey and Element models In North America, built between April 2000 and October 2002. Mazda needs to repair 14,794 units of the RX-8 and Mazda6, and Nissan has 228,000 vehicles in North America to be fixed.
Chrysler is also starting what it calls a "regional field action" to replace the inflators in the 2006 Dodge Charger, according to a company spokesperson. The company says that it has not yet found the problem in any of its vehicles, but it's being done "out of an abundance of caution." The final number of Chargers affected will be announced later this week.

2014 Nissan Juke Nismo RS amps up the funky crossover

Nissan unveiled an even hotter version of the hotter Juke Nismo at the Los Angeles Auto Show - the Juke Nismo RS, a 215-horsepower crossover that may be the most hardcore model in the compact CUV segment (until we can convince Mazda to build a Mazdaspeed CX-5, that is).
The 215 hp and 210 pound-feet of torque represent bumps of 18 hp and 26 lb-ft over the standard Juke Nismo thanks to a revised ECU, a new exhaust with a larger diameter tube, and stronger connecting rods. This amped-up engine can be mated to the owner's choice of a six-speed manual, which takes advantage of a stronger clutch cover and dual-mass flywheel, or an Xtronic continuously variable transmission (although the CVT model loses four horsepower and all of the extra torque that the Nismo RS enjoys).
"We expect drivers to feel a noticeable increase in acceleration - especially the manual transmission model - in the RS versus the regular Juke Nismo. It also holds peak torque longer. Combined with the Helical Limited-Slip Differential, which helps reduce torque steer, the sense of driving excitement is unmatched in the Juke lineup," said Pierre Loing, Nissan's vice president of product and advanced planning and strategy.