2003 Mitsubishi Galant Es Sedan 4-door 2.4l Whole Sale To Public!! on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Mitsubishi recalling i-MiEV models for brake problem

Mitsubishi is issuing a recall for the 2010-2014 i-MiEV that affects 1,810 units of the little electric car, because it's possible for the brake vacuum pump to stop working. If this happens, the result would be longer stopping distances, according to the company. The affected models were built between September 15, 2009, and March 25, 2014.
While this is just a single recall, there are actually two things that can cause this brake problem on the i-MiEV, according to Mitsubishi's filing with the National Highway Traffic Safety Administration. First, bad programming in the EV-ECU could cause the system to "falsely judge that the relay contact point is stuck," according to the full NHTSA defect notice PDF. Second, the vacuum pump exhaust hole could be corroded and blocked due to being splashed with road salt. However, the company says that if either fault happens, the brake warning lamp would illuminate, and there would be an audible alarm.
Depending on which issue is affecting an owner's i-MiEV, Mitsubishi is going to reprogram the software, replace the pump or both. Scroll down to read the recall report from NHTSA.

Mitsubishi struggling to sell doomed plant due to union workers

Mitsubishi is about to end vehicle production in the US, but the company is having serious problems finding a buyer for its Normal, IL, factory that currently assembles the Outlander Sport. A major sticking point, according to a report by The Wall Street Journal, is the plant's workforce of over 900 United Auto Workers members. The automaker has been trying to find another company to take over the site for months and has set November as the point to stop manufacturing there. The Normal, IL, factory is unique because it's the only plant in the country that's run by a Japanese automaker with a UAW-represented workforce, after starting as a joint venture with Chrysler. That makes Ford, General Motors, and FCA the preferred buyers because they could conceivably take over the union contract. However, the Blue Oval and the General likely aren't interested. According to plant officials speaking to The Wall Street Journal, FCA and some unnamed car companies are potential buyers, but there's absolutely nothing final, yet. Proponents argue that buying the location is cheaper than building a new one. Making matters harder is that the UAW and Mitsubishi are currently negotiating a new union contract, and the factory's next owner might have to take over the deal, according to the WSJ. The workers were ready to vote whether to strike recently, but that was averted when an announcement on the local's webpage said a tentative agreement was expected Sunday. Of course, the Big Three have been experiencing their own, similar issues with crafting deals, too. Related Video: