2003 Mazda Protege Lx Sedan 4-door (ruined Engine) on 2040-cars

Auto blog

Japan plans real-world diesel emissions test after companies fail

Japan's transport ministry plans to start real-world diesel emissions tests after an experiment found four models from Toyota, Nissan, and Mitsubishi that produced more nitrogen oxide (NOx) emissions than the nation's rules allow, according to The Japan Times. Regulators there usually only perform emissions checks in the lab. The VW diesel scandal has everyone double-checking their figures. Diesel versions of the Toyota Hiace van, Land Cruiser Prado, and Nissan X-Trail produced up to 10 times more NOx than allowed. The Mitsubishi Delica D:5 was up to five times over the limit, The Wall Street Journal reports. There was no evidence of defeat devices in the vehicles. Mazda performed well in the experiment, though. The CX-5 passed with nearly the same results on the road and in the lab. The Demio, better known as the Mazda2, did nearly as well with only slighter higher figures in the real world than in the controlled setting. The experimenters theorized the reason for the excessive emissions was that cold weather caused the engines' software to shut off the exhaust gas recirculation to prevent damage, according to the WSJ. However, this behavior also increased NOx production. Toyota, Nissan, and Mitsubishi don't have to worry about punishment from the transport ministry because this check was just an experiment. Their models already passed the mandated lab tests, which was the only requirement, according to The Japan Times. As governments begin greater real-world emissions tests, the results suggests diesels aren't very clean. A recent check in France found models from Ford, Renault, and Mercedes-Benz that didn't perform up to the standards. Regulators in India conducted similar evaluations and ordered VW to recall over 300,000 vehicles. Related Video:

Mazda considers expanding Takata recall nationwide

Vehicle recalls have come in force recently. Honda expanded its front driver's side Takata airbag inflator recall nationwide to cover an estimated 5.4-million vehicles, and the National Highway Traffic Safety Administration added 19 notices to its database covering safety campaigns dating back to October. It looks like there could be one more to add to the list soon because Mazda is considering a possible nationwide expansion of its own inflator repairs. A company spokesperson tells Reuters that there is no decision yet when to actually make this nationwide expansion of the driver's side inflator recall official, and the company isn't sure how many vehicles may be affected. Mazda just expanded the scope of its Takata inflator recalls to additional regions earlier in December. The move took its total number of units in need of repair from around 65,000 under the earlier NHTSA estimate to 86,773, according to the company. So far, the automaker's US campaign has included the 2003-2007 Mazda6, 2006-2007 MazdaSpeed6, 2004-2008 Mazda RX-8, 2004-2005 MPV and 2004 B-Series pickup.

Mazda goes on engineer hiring binge as recovery picks up speed

Japan's larger automakers - companies like Toyota, Honda and Nissan - have tremendous engineering talent at their disposal. That's largely because, selling as many cars as they do, they've got more revenues to tap into. Logic might dictate, then, that smaller automakers like Mazda, which no longer has the deep pockets afforded to it by its former partnership with Ford, might have less of a budget and workforce for engineering. But Mazda has been raking in record profits, and it plans on cashing those revenues in by hiring a substantial new pool of engineers.
According to Automotive News, Mazda is preparing to hire as many as 185 new engineers over the next two years - almost four times as many as the 50 engineers it previously targeted. Many of those engineers will be put to work developing the second-generation, Skyactiv 2 technologies that are on the drawing board while the first round of Skyactiv features are still being rolled out.
The boost in recruitment is enabled by a positive fiscal year that ended last March, marking the first profits Mazda had logged in four years. Sources anticipate that the fiscal year culminating at the end of this month will mark the company's most profitable yet, netting over a billion dollars to eclipse the fiscal year that ended in 2008 when it recorded $872.5 million in profits.