2010 Jeep Wrangler Rubicon Sport Utility 2-door 3.8l on 2040-cars

Auto blog

Chrysler investigating complaints of vehicles with faulty power modules

Chrysler owners are hopping mad after experiencing a series of electrical gremlins in some of the company's vehicles. Issues range from mere annoyances - windows rolling down and radios turning off of their own accord - to serious safety issues, with headlights that randomly shut off at night and cars that stall and refuse to start.
The issues are being blamed on the total integrated power module, which can cost up to $1,000 for customers to replace. This, of course, has led to a hefty batch of complaints to the National Highway Traffic Safety Administration, with 240 owners expressing their displeasure so far. Another site, CarComplaints.com, has registered over 300 complaints relating to the 2010 to 2011 Jeep Grand Cherokee and Dodge Durango, alone, according to The New York Times.
Chrysler has acknowledged that it's investigating the complaints and is analyzing the faulty TIPMs, but that isn't quite enough for customers of the affected vehicles. The newspaper has snagged a few of the more harrowing tales with the electrically challenged Chrysler products, culled from the NHTSA complaints.

FCA recalls 570,000 SUVs from Jeep and Dodge over fire woes

Fiat Chrysler US has issued two recalls covering a total of about 570,000 Jeep and Dodge models. The first concerns vanity mirror wiring in the Jeep Grand Cherokee from the 2011 and 2012 model years, and in Dodge Durango units built before September 12, 2012. The automaker recalled almost 900,000 units last year to repair the issue, then faced more issues this year when the fires continued in repaired vehicles. This new recall seeks to resolve the issue, FCA saying that the post-recall fires happened in a tiny percentage of vehicles equipped with a specific wiring package. This recall is for 352,831 total units in the US, another 26,478 in Canada, 13,037 in Mexico, and 84,330 internationally. No injuries or deaths have been reported. FCA says it will inform customers as to when they can schedule a service visit to remedy the issue. The second recall takes aim at 60,107 examples of the Jeep Compass and Patriot from the 2015 model year in the US, plus 5,755 in Canada, 3,351 in Mexico, and 23,995 in other markets. Those models could suffer from an out-of-position clamp on the power steering fluid line. The error could allow fluid to leak, increasing the risk of a fire if the fluid ends up on a hot surface. In the case of a complete loss of fluid, drivers will need to use a lot more effort to steer. The automaker reports no injuries or accidents, and will advise customers when to head to the dealer for service. Related Video: Jeep Grand Cherokee and Dodge DurangoStatement: Vanity-Mirror WiringDecember 24, 2015 , Auburn Hills, Mich. - FCA US LLC is recalling an estimated 352,831 SUVs in the U.S. to help ensure vanity-mirror wiring may be serviced more consistently.Overheating conditions were reported among a small percentage of vehicles (<0.02%) serviced in connection with a related recall, conducted previously.** An FCA US LLC investigation discovered the service procedure, if not followed precisely, may leave vehicles susceptible to a short-circuit, creating a potential fire hazard.The Company is unaware of any related injuries or accidents. Post-service overheating conditions were observed only in vehicles equipped with a certain wiring package. These vehicles were produced before Sept. 2, 2012.Affected are model-year 2011-2012 Jeep Grand Cherokee and Dodge Durango SUVs produced before Sept. 2, 2012. Wiring in the headliners of these vehicles will be secured with a new adhesive.

Jeep to stop using bad Takata airbag inflators next week

FCA is gradually ceasing to produce vehicles equipped with Takata airbag inflaters found to be inherently faulty. These airbags, which lack a certain drying agent, have been linked with dangerous premature ruptures. According to FCA, the only vehicle still in production with the named airbag is the 2016 Jeep Wrangler, and in this case they are passenger-side airbags. Fiat Chrysler says it isn't aware of any incidents involving these air bag inflaters in Jeeps, but amidst concerns that vehicles with failure-prone airbags are still being marketed to customers, North American-market 2016 Wranglers will cease to be equipped with them starting next week. As per FCA's statement, global production is expected to end by mid-September. In addition to Toledo, Ohio, the Wrangler is produced in Egypt. FCA isn't going to sell the cars with the deemed-faulty airbags without disclosing the fact to the customers: anyone buying a 2016 Wrangler will be notified that the vehicle will most likely be subject to a recall in the future, even if there is not currently a recall announced for them. NHTSA has specified a "Coordinated Remedy Program" recall schedule for the coming years, and the airbag inflaters will degrade over a time frame of several years, when subjected to a humid environment. Related Video: News Source: Fiat Chrysler Automobiles, The Wall Street JournalImage Credit: Julien Amado / Autoblog Quebec Plants/Manufacturing Recalls Chrysler Jeep Ownership Safety Takata airbag recall