2002 Jeep Wrangler Se Sport Utility 2-door 2.5l on 2040-cars

Auto blog

NHTSA upgrading Jeep Grand Cherokee, Dodge Durango headliner fire probe

The National Highway Traffic Safety Administration investigation into headliner fires experienced by a small number of Jeep Grand Cherokee and Dodge Durango owners has been upgraded to an engineering analysis, the step before the initiation of a recall. In August last year the investigation began with 146,000 Grand Cherokees from 2012 after three complaints were received, but a report on Edmunds says it has been expanded to include 593,299 vehicles covering the 2011-2013 model years for the Jeep and the Dodge Durango, which uses the same headliner assembly, because of possibly 52 incidents of fire.
In some of those incidents drivers have reported a burning odor, smoke or open flames that were contained to the headliner or migrated to another area of the passenger compartment. The culprit has apparently been found: NHTSA blaming an electrical short in the sun visor vanity light wiring, which is routed under the headliner and held in place by three screws. Chrysler began its own probe into the issue when it was first reported and is still looking into the situation while, "fully supporting the National Highway Traffic Safety Administration's investigation."

Chrysler recalling 630k Jeep models worldwide

Despite its refusal to recall 2.7 million Jeep Grand Cherokee and Liberty models this week over a gas tank fire risk, Chrysler will be recalling 630,000 Jeep Compass (pictured), Patriot and Wrangler vehicles around the globe for a pair of entirely different reasons.
The affected Compass and Patriot models are all from the 2010 to 2012 model years - 254,000 in the United States, 45,400 in Canada and 109,000 elsewhere in the world. In these models, a software error may result in the late deployment of the side airbags and seatbelt tensioners. In the event of a crash, failure of these systems could result in more serious injuries for the vehicle's occupants.
Jeep's go-anywhere Wrangler also faces a separate recall due to power steering fluid lines that can possibly wear a hole in the transmission oil cooler line. According to Chrysler, the vehicles could then leak fluid, possibly damaging the transmissions. Roughly 221,100 Wrangler models are being recalled because of this issue, all of which are fitted with Jeep's 3.6-liter Pentastar V6 engine. In the US, 181,000 vehicles are affected, with an additional 18,400 in Canada and 21,700 additional units worldwide. A Chrysler spokesperson said that no crashes or injuries have been reported with either case, according to the Associated Press.

Jeep 'trailer hitch' recall repair rates lag amidst reports of new death

The problem with exploding fuel tanks in the 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty in some rear collisions continues to be a problem for FCA US, formerly Chrysler. The campaign to fix the utility vehicles was first announced in June 2013 after 51 claimed fatalities, and the fixes reportedly began in January 2014. However, there continue to be new deaths blaming the problem in unrepaired models, according to The Detroit News, citing data from the Center for Auto Safety. The automaker initially refused NHTSA's pressuring to conduct a recall because the models met applicable crash standards when they were manufactured, but eventually, there was a compromise to inspect and fix about 1.56 million Jeeps. With the fuel tank located between the rear axle and bumper, the unusual fix was to install a trailer hitch for extra protection. The National Highway Traffic Safety Administration later agreed that the change would provide added safety in lower to medium speed crashes, but not high-speed crashes. The most recent fatality, according to The Detroit News, occurred on a Michigan freeway in November 2014 when a pregnant woman in a 2003 Liberty was rear-ended when traffic slowed. Her Jeep impacted the vehicle in front, rolled over and a fire resulted. The family reportedly plans to file a lawsuit against FCA. At issue has been the rate at which the vehicles are being fixed. In July 2014, the automaker estimated it could have all of the vehicles repaired by March 2015 thanks to additional hitch supplies. But by November, NHTSA claimed that only three percent of the recalled models had been fixed. FCA says it continues to work to notify owners, though. According to Chrysler spokesperson Eric Mayne to Autoblog, "We are processing approximately 1,200 vehicles per day. Every owner who schedules service is receiving service. As of Jan. 8, that total was 193,490." The company has also mailed out over two million notifications to owners, more than the number officially called in. Given the age of these Jeeps, many of them have had multiple owners, and historically, the older a vehicle is, the less likely the recall fixes are to be carried out. FCA is currently creating a video urging people to have the hitch installed to be released soon. News Source: The Detroit News [1], [2]Image Credit: Jeep Recalls Jeep Safety SUV FCA jeep liberty jeep safety