1998 Jeep Grand Cherokee Laredo on 2040-cars

Auto blog

NHTSA closes investigation on 4.7M FCA power modules, no recall

FCA US hasn't had the best time with recalls as of late. Not only did the company recently agree to greater safety oversight and paid $105 million to the government, that came just days after hacking fears prompted a 1.4-million model recall campaign. However, a recent decision to close an investigation by the National Highway Traffic Safety Administration means that the automaker doesn't have to worry about another major recall possibly affecting 4.7 million vehicles, according to the agency's report (as a PDF). Last September, the Center for Auto Safety petitioned NHTSA to investigate an alleged problem with the totally integrated power module (TIPM) on these FCA US models. The group claimed that a fault with the component could cause a variety of maladies, including stalls, not starting, catching fire, unintended acceleration, and airbag non-deployment. At the time, it also submitted 70 cases where this had reportedly happened. According to NHTSA, "no valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration, or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components." The agency did find signs of an issue with the fuel pump relay in some Jeep Grand Cherokees and Dodge Durangos, but FCA US issued recalls for the problem in September 2014 and February 2015. Without anything else to go on, the Feds don't think it's worth investigating this topic any more.

Fires, deaths continue after Jeep fuel tank recall

As Kayla White slowed her SUV behind two other cars to exit a suburban Detroit freeway on Veterans Day, it was rammed from behind by a Cadillac STS. Her red 2003 Jeep Liberty bounced off a Nissan in front of it, rolled onto its side and exploded in flames. Other drivers ran to help but were forced back by the heat. Firefighters arrived in just three minutes but were too late. White, a 23-year-old restaurant hostess who was eight months pregnant, died of burns and smoke inhalation. White is one of more than 70 people killed in fires involving older Jeeps with plastic fuel tanks mounted behind the rear axle. Fiat Chrysler, which makes Jeeps, recalled 1.56 million of them in June 2013 under pressure from US safety regulators. But only 12 percent of the SUVs have been repaired in the 18 months since the recall, a much slower pace than usual. And White's Jeep was not among those fixed. Last week, prosecutors charged the Cadillac driver with committing a moving violation that caused a death. But safety advocates and the lawyer for White's family say the blame belongs as much, if not more, on Chrysler and an auto-industry safety system that moves too slowly to prevent tragedy. The rear-mounted tanks have little structure to protect them if struck from behind, making them susceptible to punctures and fires. Moving the gas tank in front of the axle would be expensive and difficult. So Chrysler's remedy involved installing trailer hitches on the rear of the Jeeps as an extra layer of protection. Government testing showed the hitches protected the tanks in crashes up to 40 mph when stationary Jeeps were hit from behind. But at higher speeds, they wouldn't help. White tried to get the repair done a few weeks before her death but was told by a Jeep dealer that parts weren't available, according to Gerald Thurswell, her family's lawyer. He wouldn't identify the dealership, and his contention could not be independently verified by The Associated Press. Thurswell contends the gas tank ruptured, spilling fuel that touched off the fire. A Chrysler spokesman expressed sympathy to White's family but said the company had no written proof that she asked a dealer about the recall. Two crash reconstruction experts interviewed by the AP say gas wouldn't have spilled from White's Jeep if the tank had been mounted in front of the rear axle. Both say a hitch might have prevented the tank from being damaged, but because both vehicles were in motion, neither expert could say for sure.

Stellantis suspends vehicle production in Russia

MILAN - Stellantis on Tuesday said it was suspending production at its Russian plant due to logistical difficulties and sanctions imposed on Moscow. The world's fourth-largest automaker, which produced and sold the Peugeot, Citro¸n, Opel, Jeep, and Fiat brands in Russia, has just 1% of the country's car market. It runs a van-making plant in Kaluga, around 125 miles (201 kilometres) southeast of Moscow, co-owned with Japanese carmaker Mitsubishi, which halted production at the facility earlier this month. "Given the rapid daily increase in cross sanctions and logistical difficulties, Stellantis has suspended its manufacturing operations in Kaluga to ensure full compliance with all cross sanctions and to protect its employees," Stellantis said in a statement. The plant employs 2,700 people. The company will continue to pay salaries through a local downtime scheme and by using anticipated vacation periods, Stellantis told Reuters. It said it did not know how long the stoppage would last, adding that its priority was its staff and the return of peace. Stellantis had already suspended all exports and imports of vehicles with Russia, following Moscow's invasion of Ukraine, moving production to western Europe. It had also said it was freezing plans for more investments in the country. Van production in Kaluga had remained just for the local market. Scores of foreign companies have announced temporary shutdowns of stores and factories in Russia or said they were leaving the country for good since Russia began what it calls "a special military operation" in Ukraine on Feb. 24. Stellantis Chief Executive Carlos Tavares in late March said the group would have to close the Kaluga plant shortly as it was running out of parts. Separately on Tuesday, General Motors Co said it was extending its suspension of business in Russia due to the conflict and international sanctions. The U.S. automaker, which initially suspended imports into Russia and commercial activity on Feb. 28, said it was laying off most of its 66 employees and providing them with separation packages. GM does not have plants in Russia and only sold about 3,000 vehicles annually there prior to the suspension. (Additional reporting by Ben Klayman in Washington; Editing by Mark Potter and Mark Porter) Government/Legal Plants/Manufacturing Fiat Jeep Citroen Opel Peugeot