1986 Jeep Cj7 on 2040-cars

Auto blog

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.

Chrysler recalls 468,700 Jeep Grand Cherokees, Commanders over rollaway risk

Chrysler has issued a recall covering a combined 469,000 units of the 2005-2010 Jeep Grand Cherokee and the 2006-2010 Jeep Commander (inset). Of that number, 295,000 are in the US, roughly 33,000 in Canada and Mexico and the remainder in other markets. It seems an electrical fault in the transfer case can allow the affected SUVs to shift into neutral on their own, while an Associated Press report says that Chrysler had "found cracks in a circuit board that turns the four-wheel-drive system on and off." The issue was discovered when an owner started his car remotely and it rolled away.
Chrysler is expected to begin notifying owners in June 2013, who can then take their cars to dealers. The dealer will reflash the final drive controller free of charge. There's a bulletin from the National Highway Traffic Safety Administration below with more information.

Toledo continues fight for Jeep Wrangler production, despite mayor's death

Where will the next-generation Jeep Wrangler be built? That's an open question, but it's one that the city of Toledo, OH desperately wants to be the answer to. The city suffered a major blow, though, with the death of Mayor Michael Collins earlier this month. Collins had been the city's biggest champion during talks with Fiat Chrysler Automobiles, before suffering a fatal heart attack on Feb. 6. But Collins' tragic death isn't dampening the city's desire to carry on as the home of the Wrangler. "The mayor's passing is tragic. But on Monday, when I came to work, I knew exactly what I needed to do and exactly what needed to be done," the city's director of development, Matt Sapara, told the Detroit Free Press. According to the Freep, Sapara said Toledo and the state of Ohio have delivered an outline of a development plan that would give FCA the ability to buy an extra 100 acres to expand the factory. This is to help accommodate FCA's targeted output of 300,000 to 350,000 next-generation Wranglers, up from the 240,000 the factory can make now. "Our target in the proposal is to provide a way to increase the production capacity to a number that allows Fiat Chrysler to meet its business model," Sapara told the Freep, adding that the land could be available later this summer. FCA, meanwhile, has shown a somewhat ambivalent attitude towards Toledo production, with CEO Sergio Marchionne openly discussing the pros and cons of continuing to build the Wrangler south of the Michigan border. "We are going to take a very hard look at this without ignoring what these guys have done," Marchionne told the Free Press at last month's Detroit Auto Show, adding that he'd like to keep production there, provided the cost of retooling is comparable to relocating to another facility. Related Video: