2020 Jeep Wrangler Rubicon on 2040-cars

Auto blog

NHTSA upgrading Jeep Grand Cherokee, Dodge Durango headliner fire probe

The National Highway Traffic Safety Administration investigation into headliner fires experienced by a small number of Jeep Grand Cherokee and Dodge Durango owners has been upgraded to an engineering analysis, the step before the initiation of a recall. In August last year the investigation began with 146,000 Grand Cherokees from 2012 after three complaints were received, but a report on Edmunds says it has been expanded to include 593,299 vehicles covering the 2011-2013 model years for the Jeep and the Dodge Durango, which uses the same headliner assembly, because of possibly 52 incidents of fire.
In some of those incidents drivers have reported a burning odor, smoke or open flames that were contained to the headliner or migrated to another area of the passenger compartment. The culprit has apparently been found: NHTSA blaming an electrical short in the sun visor vanity light wiring, which is routed under the headliner and held in place by three screws. Chrysler began its own probe into the issue when it was first reported and is still looking into the situation while, "fully supporting the National Highway Traffic Safety Administration's investigation."

NHTSA investigating 630k Jeep Wranglers for possible airbag fault

The National Highway Traffic Safety Administration is opening a preliminary evaluation into a possible wiring problem on some 2007-2012 Jeep Wrangler models that could affect airbag deployment. The government agency has 221 complaints alleging that the airbag warning light is illuminating, and that could indicate that the safety devices might not deploy in a crash. If a recall is necessary, an estimated 630,000 vehicles could be affected. According to the documents from NHTSA (as a PDF here), a "faulty clockspring assembly in the driver side airbag electrical circuit" could be the culprit. Also, some of the affected Wranglers are showing a fault code that indicates the safety device wouldn't deploy in an accident. However at this time, there are no reports of injuries related to this potential problem. NHTSA's preliminary evaluations are simply meant to investigate and don't necessarily lead to a recall. This isn't the first time for a potential problem like this on the Wrangler, though. A clockspring issue already led to a safety campaign for 2008-2012 right-hand drive Wranglers and an extended warranty for 2007 left-hand drive examples. Related Video: INVESTIGATION Subject : Air Bag Clockspring Wiring Failure Date Investigation Opened: JUN 19, 2015 Date Investigation Closed: Open NHTSA Action Number: PE15025 Component(s): AIR BAGS All Products Associated with this Investigation Vehicle Make Model Model Year(s) JEEP WRANGLER 2007-2012 JEEP WRANGLER 2-DR 4X4 2007-2009 JEEP WRANGLER 4-DR 4X2 2007-2009 JEEP WRANGLER 4-DR 4X4 2007-2009 JEEP WRANGLER SAHARA 2007 Details Manufacturer: Chrysler (FCA US LLC) SUMMARY: The subject vehicles display an airbag warning light that may indicate a failure of the clockspring wiring in the driver side air bag circuit. Several complaints cite the following diagnostic trouble code (DTC): Code B1B02 Open Squib to driver's air bag. This DTC would indicate a no-fire condition (disablement) for the driver air bag. ODI investigated the RHD (right hand drive) Wrangler for a clockspring issue under PE11-019 which led to NHTSA Recall 11V258 on model year (MY) 2008-2012 RHD Wranglers as well as an extended warranty campaign on MY 2007 LHD Wrangler vehicles. This investigation covers the MY07-12 LHD (left hand drive) Wranglers.

2.1 million vehicles recalled again over faulty airbags

Fiat Chrysler Automobiles, Honda and Toyota will recall 2.1 million vehicles to fix faulty airbag modules "after the manufacturers' original attempts to fix the defects proved ineffective in some vehicles." These vehicles had all previously been recalled, but the National Highway Traffic Safety Administration found that the airbags could still potentially malfunction. This recall will cover Acura MDX, Dodge Viper, Jeep Grand Cherokee, Honda Odyssey, Pontiac Vibe, Toyota Corolla, Toyota Matrix and Toyota Avalon models made in the early 2000s. NHTSA has reportedly received about 40 reports of airbag deployment in such vehicles, even though the vehicle had not been involved in a crash. Roughly one million of these same vehicles, all from Honda and Toyota, are also subject to recalls due to faulty Takata airbag modules, though this particular recall is for "an electronic component manufactured by TRW" that is separate from the actual airbags from Takata. According to NHTSA Administrator Mark Rosekind: "This is unfortunately a complicated issue for consumers, who may have to return to their dealer more than once. But this is an urgent safety issue, and all consumers with vehicles covered by the previous recalls should have that remedy installed. Even though it's a temporary solution until the new remedy is available, they and their families will be safer if they take the time to learn if their vehicle is covered and follow their manufacturers' instructions. A hassle is much better than a family tragedy." If you're the owner of an affected car, expect to hear more from the official automaker and government channels in short order. In the meantime, we'd suggest getting your car checked and fixed at your local dealer. The official statement and recall information can be found below. Previously Recalled Vehicle Remedies Not Working as Designed; NHTSA Announces Follow up Recall of 2.12 Million Cars and SUVs Saturday, January 31, 2015 Contact: Gordon Trowbridge, 202-366-9550, Public.Affairs@dot.gov WASHINGTON – U.S. Transportation Secretary Anthony Foxx announced today the recall of more than 2.12 million Acura, Dodge, Jeep, Honda, Pontiac, and Toyota vehicles for a defect that may cause airbags to deploy inadvertently. The recalls will provide vehicle owners with a new remedy after the manufacturers' original attempts to fix the defects proved ineffective in some vehicles.