2013 Jeep Wrangler Unlimited Sport on 2040-cars

Auto blog

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.

Georgia jury awards $150 million in Jeep fire case

FCA US continues to fight allegations that some Jeep Grand Cherokee and Liberty sport-utility vehicles are unsafe because of the possibility of fires in rear-end collisions. In one recently decided case, a jury in Georgia awarded $150 million in damages to a family whose child died in a blaze in 2012 in a 1999 Grand Cherokee. The jury believed that FCA acted with "reckless and wanton disregard," and didn't do enough to warn owners, according to Reuters. The automaker was found liable for 99 percent of the damages, and the remaining one percent was for the driver who rear-ended the family's SUV. In a statement from FCA US, the company said that it is considering an appeal. Under Georgia law, the automaker was allegedly unable to present a three-year investigation of rear-impact data to jurors. This was the same information the National Highway Traffic Safety Administration used to decide that the '99 Grand Cherokee "did not pose an unreasonable risk to motor vehicle safety." The original recall for the models covered 1.56 million examples of the 2002-2007 Liberty and 1993-1998 Grand Cherokee. With the fuel tank located between the rear axle and bumper, NHTSA and FCA eventually agreed to install a trailer hitch for extra protection. A further 1.2 million 1999-2004 Grand Cherokees owners received notice of a customer service action to have their vehicles inspected, though no hitch installed. Subsequent tests showed this remedy to be effective for impacts below 40 miles per hour. The automaker has maintained the SUVs met the applicable safety standards of the period when they were built. The company was chastised by NHTSA last year for low repair rates of the problem. FCA US LLC Statement Regarding Walden v Chrysler Group Verdict: April 2, 2015 , Auburn Hills, Mich. - FCA US is disappointed and will consider an appeal of this verdict. It is unfortunate that under Georgia Law the jury was prevented from taking into account extensive data submitted to NHTSA during a three year investigation, which included more than 20 years of rear impact accident data for tens of millions of vehicles. This and other information provided the basis for NHTSA's determination that the 1999 Jeep Grand Cherokee did not pose an unreasonable risk to motor vehicle safety.

Jeep gunning to build 250,000 Cherokees a year

Contrary to what a certain politician may have said last year about Jeep moving to China, the automaker is in fact doing the opposite, with plans to greatly increase the production capacity at its Toledo North Assembly plant in Ohio. The Detroit Free Press is reporting that there are big plans for the 2014 Jeep Cherokee and Toledo North, as a local union president has informed the newspaper that Chrysler is planning to produce around 250,000 examples of the new midsize utility per year.
To put this number into context, 250,000 units is more than what Jeep Liberty sales totaled here over the last three years combined. Even taking into consideration that the 250,000 units will be distributed beyond US borders, that's an ambitious volume figure full-stop - and that's without taking into consideration the new Cherokee's love/hate design. In its favor, though, Jeep is making remarkable inroads globally as of late, and the Cherokee's size could work well in emerging markets. To get that kind of output from Toledo's Cherokee assembly line, Chrysler will reportedly hire 1,105 new workers - that's in addition to the 200 workers already being hired to build the popular Jeep Wrangler, which is itself expected to top 220,000 units this year.