2011 Wrangler Unlimited Rubicon 4x4 Lifted! $14,000 In Extras! Call Us Toll Free on 2040-cars

Auto blog

NHTSA investigating 2015 Jeep Cherokee after new owner's total-loss fire [w/video]

The National Highway Traffic Safety Administration has opened a Preliminary Evaluation into the 2015 model year Jeep Cherokee after a single example caught on fire in California. This investigation will decide the cause, scope and frequency of this possible problem and will decide whether a recall is necessary for 50,415 potentially affected examples. According to Automotive News, the Cherokee's owner only purchased the CUV about two days before the fire, and it had been driven less than 100 miles. The new buyer reported parking the Jeep, and noticed a smell like smoke. Shortly after, the vehicle was consumed in flames. There were no injuries, but much of the incident was captured on video. NHTSA is also trying to decide whether another report is related. In this case, a driver noticed smoke under the hood of a 2015 Cherokee with just 45 miles on it, while driving at 60 miles per hour. According to the complaint to the agency, "the vehicle was not diagnosed or repaired," but FCA was notified. Read below NHTSA's announcement of the Preliminary Evaluation. CBS News 8 - San Diego, CA News Station - KFMB Channel 8 INVESTIGATION Subject : Engine compartment fire Date Investigation Opened: JAN 13, 2015 Date Investigation Closed: Open NHTSA Action Number: PE15003 Component(s): ENGINE Vehicle Make Model Model Year(s) JEEP CHEROKEE 2015 Manufacturer: Chrysler (FCA US LLC) SUMMARY: The Office of Defects Investigation (ODI) has received one complaint (VOQ) of engine compartment fire in model year (MY) 2015 Jeep Cherokee vehicles alleging a severe engine compartment fire incident resulting in a total vehicle loss (VOQ # 10672201). The consumer alleges that the entire vehicle was engulfed in flames approximately 20 feet high within seconds of parking the vehicle. The complaint alleged white smoke coming from under the hood immediately after parking the vehicle and while the ignition is off. In addition, ODI has identified field report data submitted as part of Early Warning Reporting that relate to the alleged defect. A Preliminary Evaluation has been opened to assess the cause, scope and frequency of the alleged defect. The following VOQ numbers are associated with the issues discussed in this opening resume: 10670034, 10672201.

NHTSA closes investigation on 4.7M FCA power modules, no recall

FCA US hasn't had the best time with recalls as of late. Not only did the company recently agree to greater safety oversight and paid $105 million to the government, that came just days after hacking fears prompted a 1.4-million model recall campaign. However, a recent decision to close an investigation by the National Highway Traffic Safety Administration means that the automaker doesn't have to worry about another major recall possibly affecting 4.7 million vehicles, according to the agency's report (as a PDF). Last September, the Center for Auto Safety petitioned NHTSA to investigate an alleged problem with the totally integrated power module (TIPM) on these FCA US models. The group claimed that a fault with the component could cause a variety of maladies, including stalls, not starting, catching fire, unintended acceleration, and airbag non-deployment. At the time, it also submitted 70 cases where this had reportedly happened. According to NHTSA, "no valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration, or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components." The agency did find signs of an issue with the fuel pump relay in some Jeep Grand Cherokees and Dodge Durangos, but FCA US issued recalls for the problem in September 2014 and February 2015. Without anything else to go on, the Feds don't think it's worth investigating this topic any more.

What's really going on with the 2014 Jeep Cherokee's transmission issues?

On September 23, Automotive News reported that Chrysler had idled the second shift workers it hired just five weeks prior at its Toledo Assembly Complex to build the 2014 Jeep Cherokee. At the time, Chrysler said it had "built the critical number of vehicles we need to stock dealerships once containment is released" and did not want "to put additional strain on our logistics partners ... upon release." That reasoning was not only unusual, it didn't seem to make sense.
It appears the center of the nine-speed issue is software, not hardware.
That same day, the Detroit News ran a piece claiming workers at the Toledo factory said the halt was due to issues with the Cherokee's transmission. It put the number of already-built Cherokees needing fixes at 1,000 and said that some of the workers not laid off had been instructed "to take the Jeep on long test-drives." That made more sense. Three days later, on September 26, Automotive News reported that the 500 workers laid off had been reinstated, with engineers "speeding repairs on the SUV's powertrain software." The AN piece didn't put a number on how many units are being fixed, but it did say that 12,000 have been built and are awaiting delivery to dealers. The best it could say about when dealers will get them, however, is that "progress on a fix is being made. It's unclear when shipments to dealers will start."