2007 Jeep Wrangler Rubicon on 2040-cars

Auto blog

FCA recalls 894k total vehicles worldwide in two campaigns

FCA is recalling a total of 893,698 vehicles worldwide in two campaigns to fix problems with inadvertent airbag deployment, failure of the anti-lock brakes, and stability control systems in the Jeep Grand Cherokee, Liberty, Dodge Journey, and Fiat Freemont. 559,703 of these vehicles are in the US. The larger recall affects 284,089 examples of the 2003 Jeep Liberty and 2004 Jeep Grand Cherokee, and there are also 13,411 of them in Canada, 6,277 in Mexico, and 48,212 outside the NAFTA region. Because of "electrical noise beyond the tolerance of the airbag electronic control module", part of that component can fail, according to the National Highway Traffic Safety Administration. This can cause the front and side airbags to deploy and the seatbelt pre-tensioners to activate inadvertently. FCA US has seven reports of alleged injuries from this problem. To fix the situation, the Jeeps need their Occupant Restraint Control modules replaced, as well as the front- and side-impact sensors. According to the NHTSA, the replacement parts won't be available until early 2016. Still, FCA US will advise owners about the problem in a letter by the end of December and will send a second notification when the components are ready. The second campaign affects 275,614 examples of the 2012-2015 Dodge Journey in the US; plus 78,148 of them in Canada, 36,471 in Mexico, and 151,476 left-hand drive units outside of NAFTA where it's sold as the Fiat Freemont. On these vehicles, water intrusion can disable the anti-lock brakes and electronic stability control, although a warning light often illuminates when this issue occurs, and the problem doesn't affect regular braking. There are also no reports of injuries or accidents. To fix the issue, dealers will seal the ABS wiring harness and will replace any already affected components as necessary, like the ABS module or the headlamp and dashboard wiring harness. Statement: Occupant Restraint Control Modules October 30, 2015 , Auburn Hills, Mich. - FCA US LLC is voluntarily recalling an estimated 284,089 older-model SUVs in the U.S. to replace their Occupant Restraint Control (ORC) modules and front and/or side-impact sensors, as required. Within this vehicle population, FCA US became aware of seven injuries caused by inadvertent air-bag deployments and advised NHTSA accordingly. The affected vehicles are not equipped with Takata Corp. air-bags. The Company is unaware of any related accidents.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.

Jeep 'trailer hitch' recall repair rates lag amidst reports of new death

The problem with exploding fuel tanks in the 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty in some rear collisions continues to be a problem for FCA US, formerly Chrysler. The campaign to fix the utility vehicles was first announced in June 2013 after 51 claimed fatalities, and the fixes reportedly began in January 2014. However, there continue to be new deaths blaming the problem in unrepaired models, according to The Detroit News, citing data from the Center for Auto Safety. The automaker initially refused NHTSA's pressuring to conduct a recall because the models met applicable crash standards when they were manufactured, but eventually, there was a compromise to inspect and fix about 1.56 million Jeeps. With the fuel tank located between the rear axle and bumper, the unusual fix was to install a trailer hitch for extra protection. The National Highway Traffic Safety Administration later agreed that the change would provide added safety in lower to medium speed crashes, but not high-speed crashes. The most recent fatality, according to The Detroit News, occurred on a Michigan freeway in November 2014 when a pregnant woman in a 2003 Liberty was rear-ended when traffic slowed. Her Jeep impacted the vehicle in front, rolled over and a fire resulted. The family reportedly plans to file a lawsuit against FCA. At issue has been the rate at which the vehicles are being fixed. In July 2014, the automaker estimated it could have all of the vehicles repaired by March 2015 thanks to additional hitch supplies. But by November, NHTSA claimed that only three percent of the recalled models had been fixed. FCA says it continues to work to notify owners, though. According to Chrysler spokesperson Eric Mayne to Autoblog, "We are processing approximately 1,200 vehicles per day. Every owner who schedules service is receiving service. As of Jan. 8, that total was 193,490." The company has also mailed out over two million notifications to owners, more than the number officially called in. Given the age of these Jeeps, many of them have had multiple owners, and historically, the older a vehicle is, the less likely the recall fixes are to be carried out. FCA is currently creating a video urging people to have the hitch installed to be released soon. News Source: The Detroit News [1], [2]Image Credit: Jeep Recalls Jeep Safety SUV FCA jeep liberty jeep safety