2005 Jeep Wrangler Rubicon Unlimited on 2040-cars

Auto blog

Chrysler recalls small number of 2013-2014 cars and trucks over engine debris

Chrysler is recalling a small number cars over issues with their 2.4-liter four-cylinder engines. The recall, which affects 522 examples of its 2013 Dodge Avenger and Chrysler 200 models, as well as 2014 Jeep Compass and Patriot CUVs has to do with potential debris in the balance shaft bearings.
The abrasive stuff can cause the oil pressure to drop, which could lead to the engine stalling or outright failure. This situation could at best leave drivers stranded and at worst lead to a crash.
Chrysler will begin notifying owners, who will need to report in to have the balance shaft module replaced. All repairs are naturally free of charge. Scroll down for the bulletin from NHTSA.

Chrysler Recalling Nearly 907,000 Cars, SUVs

Nearly 907,000 Chrysler, Dodge and Jeep SUVs and cars are being recalled for alternators that can fail and heated power mirror wiring that can short and cause minor fires. The recalls, posted Thursday by U.S. safety regulators, push the total number of recalls so far this year 544, totaling a record of more than 52 million vehicles. The largest of Thursday's recalls covers nearly 470,000 Jeep Grand Cherokees, Chrysler 300s, and Dodge Chargers, Challengers and Durangos from the 2011 through 2014 model years. The alternators can fail, causing the 3.6-liter V6 engines to stall unexpectedly. The problem also can cause the electrical system to fail, as well as knock out power-assisted steering, antilock brakes and electronic stability control. It can even cause fire or smoke, according to documents Chrysler filed with the U.S. National Highway Traffic Safety Administration. NHTSA opened an investigation into the problem in July, and Chrysler began its own probe in August. The company analyzed warranty complaints and alternators that had failed. The alternator generates electricity to recharge the battery and run other devices. Chrysler investigators traced the problem to heat fatigue in an alternator diode. Chrysler said it received 322 complaints about the problem, while 55 people complained to NHTSA. The company said it knows of one crash related to the problem, but no injuries or fires. The company will replace the alternators with upgraded versions for free. Owners will be notified in November. The company says customers who see warning lights or suspect a problem should contact their dealers. The recall affects cars and SUVs sold mainly in the U.S. and Canada, but some were sold in Mexico and overseas markets. The second recall covers almost 437,000 Jeep Wranglers from 2011 through 2013. Water can find its way into the heated power mirror wiring harness and cause corrosion. That can cause a short and could cause a minor fire and smoke, as well as cause loss of function of the mirror. The problem was discovered in February after three Wranglers in Canada were damaged. Chrysler says it has 26 complaints about the problem, but it knows of no fires, crashes or injuries. Dealers will move the wiring and install a protective shield to keep water out at no cost to owners, starting in December. Most of the Wranglers are in the U.S., Canada and Mexico, but more than 78,000 were sold overseas.

Jeep 'trailer hitch' recall repair rates lag amidst reports of new death

The problem with exploding fuel tanks in the 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty in some rear collisions continues to be a problem for FCA US, formerly Chrysler. The campaign to fix the utility vehicles was first announced in June 2013 after 51 claimed fatalities, and the fixes reportedly began in January 2014. However, there continue to be new deaths blaming the problem in unrepaired models, according to The Detroit News, citing data from the Center for Auto Safety. The automaker initially refused NHTSA's pressuring to conduct a recall because the models met applicable crash standards when they were manufactured, but eventually, there was a compromise to inspect and fix about 1.56 million Jeeps. With the fuel tank located between the rear axle and bumper, the unusual fix was to install a trailer hitch for extra protection. The National Highway Traffic Safety Administration later agreed that the change would provide added safety in lower to medium speed crashes, but not high-speed crashes. The most recent fatality, according to The Detroit News, occurred on a Michigan freeway in November 2014 when a pregnant woman in a 2003 Liberty was rear-ended when traffic slowed. Her Jeep impacted the vehicle in front, rolled over and a fire resulted. The family reportedly plans to file a lawsuit against FCA. At issue has been the rate at which the vehicles are being fixed. In July 2014, the automaker estimated it could have all of the vehicles repaired by March 2015 thanks to additional hitch supplies. But by November, NHTSA claimed that only three percent of the recalled models had been fixed. FCA says it continues to work to notify owners, though. According to Chrysler spokesperson Eric Mayne to Autoblog, "We are processing approximately 1,200 vehicles per day. Every owner who schedules service is receiving service. As of Jan. 8, that total was 193,490." The company has also mailed out over two million notifications to owners, more than the number officially called in. Given the age of these Jeeps, many of them have had multiple owners, and historically, the older a vehicle is, the less likely the recall fixes are to be carried out. FCA is currently creating a video urging people to have the hitch installed to be released soon. News Source: The Detroit News [1], [2]Image Credit: Jeep Recalls Jeep Safety SUV FCA jeep liberty jeep safety