2010 Jeep Patriot 4wd Sport on 2040-cars

Auto blog

Fires, deaths continue after Jeep fuel tank recall

As Kayla White slowed her SUV behind two other cars to exit a suburban Detroit freeway on Veterans Day, it was rammed from behind by a Cadillac STS. Her red 2003 Jeep Liberty bounced off a Nissan in front of it, rolled onto its side and exploded in flames. Other drivers ran to help but were forced back by the heat. Firefighters arrived in just three minutes but were too late. White, a 23-year-old restaurant hostess who was eight months pregnant, died of burns and smoke inhalation. White is one of more than 70 people killed in fires involving older Jeeps with plastic fuel tanks mounted behind the rear axle. Fiat Chrysler, which makes Jeeps, recalled 1.56 million of them in June 2013 under pressure from US safety regulators. But only 12 percent of the SUVs have been repaired in the 18 months since the recall, a much slower pace than usual. And White's Jeep was not among those fixed. Last week, prosecutors charged the Cadillac driver with committing a moving violation that caused a death. But safety advocates and the lawyer for White's family say the blame belongs as much, if not more, on Chrysler and an auto-industry safety system that moves too slowly to prevent tragedy. The rear-mounted tanks have little structure to protect them if struck from behind, making them susceptible to punctures and fires. Moving the gas tank in front of the axle would be expensive and difficult. So Chrysler's remedy involved installing trailer hitches on the rear of the Jeeps as an extra layer of protection. Government testing showed the hitches protected the tanks in crashes up to 40 mph when stationary Jeeps were hit from behind. But at higher speeds, they wouldn't help. White tried to get the repair done a few weeks before her death but was told by a Jeep dealer that parts weren't available, according to Gerald Thurswell, her family's lawyer. He wouldn't identify the dealership, and his contention could not be independently verified by The Associated Press. Thurswell contends the gas tank ruptured, spilling fuel that touched off the fire. A Chrysler spokesman expressed sympathy to White's family but said the company had no written proof that she asked a dealer about the recall. Two crash reconstruction experts interviewed by the AP say gas wouldn't have spilled from White's Jeep if the tank had been mounted in front of the rear axle. Both say a hitch might have prevented the tank from being damaged, but because both vehicles were in motion, neither expert could say for sure.

Chrysler adding 200 jobs at Ohio Jeep Wrangler plant

Chrysler is betting that the Jeep Wrangler will continue its strong sales surge as it continues to push the legendary brand out across the globe. The Auburn Hills automaker is reportedly adding 200 workers at the Toledo, Ohio plant that builds the Wrangler. What's more, those new hires will be at their posts quickly - they'll be on the job by April 1. Of those 200 workers, 130 employees will be there to relieve those who need breaks.
Why do they need so many relief workers? The Toledo Jeep Complex is currently working at a torrid pace with two ten-hour shifts. A third shift has been ruled out for the moment because of a production botttleneck - the plant's paint shop is already maxed out. According to Reuters, Wrangler production in 2012 cleared 200,000 units, and US sales were up by 16 percent.
Another part of the Toledo plant is presently down as Chrysler retools the line to build Jeep's divisively styled Liberty replacement, the Cherokee (seen in our gallery below). Production for the new model is scheduled to begin toward the end of May.

Jeep recalls 228k Cherokees over airbag deployment fears

Jeep is recalling an estimated 228,181 examples of the 2014 and 2015 Jeep Cherokee worldwide because the airbags can inadvertently deploy in some situations. Specifically, the campaign covers 168,092 vehicles in the US, 19,557 in Canada, 4,133 in Mexico and 36,399 outside of North America. According to Jeep, the problem occurs when drivers execute extremely hard handling maneuvers and upset the vehicle's balance, which causes the side-curtain and seat-mounted side airbags to deploy. "The air-bag systems, sensing potential rollovers, automatically activated," according to the automaker's announcement. While this occurred in "a small number" of cases, according to Jeep, the problem caused no reported injuries or accidents. To fix the fault, the company will issue a software update to recalibrate the bags' deployment. Statement: Restraint-System Software Upgrade February 2, 2015 , Auburn Hills, Mich. - FCA US LLC is launching a global recall of an estimated 228,181 SUVs to upgrade software governing side-curtain and seat-mounted side air bags. The action follows an investigation by FCA US engineers after a small number of inadvertent deployments involving drivers who executed extreme maneuvers. These maneuvers dramatically changed the vehicles' angle of operation, relative to the ground. The air-bag systems, sensing potential rollovers, automatically activated. FCA US is unaware of any related injuries or accidents. The software upgrade will recalibrate the threshold for deployment and the vehicles will remain compliant with all applicable safety regulations. Affected are certain 2014 and 2015 Jeep Cherokees. Estimated volumes by market are as follows: 168,092 in the U.S.; 19,557 in Canada; 4,133 in Mexico and 36,399 outside the NAFTA region. The Company will notify affected customers. Software will be available at that time. Customers with additional concerns or questions may call 1-800-853-1403. Featured Gallery 2015 Jeep Cherokee View 41 Photos News Source: FCA USImage Credit: Jeep Recalls Jeep Safety Crossover