1977 Jeep Cj5 Off Road 4x4 Rock Crawler on 2040-cars

Auto blog

Dodge and Jeep recalling 895k SUVs for possibility of headliner fires

Dodge and Jeep are announcing recalls of a total of 895,000 Durango and Grand Cherokee models worldwide from the 2011 through 2014 model years. There's a possibility that the wiring in the sun visor can short circuit and cause a fire. It specifically affects vehicles built between January 5, 2010, and December 11, 2013, and there are approximately 651,000 of them in the US, 45,700 in Canada, 23,000 in Mexico and 175,000 outside of North America.
Screws that fasten the sunvisor to the headliner may pierce wires in the visor, if the part has been removed or serviced, potentially causing a fire risk. If the wires short circuit, they could overheat and potentially combust. The automakers report three injuries caused by this defect, and according to the investigation by the National Highway Traffic Safety Administration, "there may be a total of 52 unique fire incidents."
To fix the problem, Dodge and Jeep will inspect the vehicles for suspect wiring, and all of the models, whether damaged or not, will get a new sun visor spacer with a wire guide to stop the possibility of short circuits. According to the automakers' announcement, "this condition is not present in vehicles which have not had the headliner or vanity mirror serviced." They will notify affected owners, and repairs will begin in August.

Jeep Grand Cherokee, Dodge Durango still catching fire after recall

Automakers issue recalls all the time. It's part of the cost of doing business. We just assume that once the recall has been carried out, the problem in question has been fixed. But that's not always the case, as this latest investigation being undertaken by the National Highway Traffic Safety Administration goes to show. The problem stems back to a recall issued by Chrysler last summer. It revolved rather the sun visor in the SUVs it makes at its Jefferson North Assembly Plant – specifically, the screw affixing the sun visor could end up rubbing against the wiring for the lamp in the vanity mirror, potentially causing an electrical short and even a fire. 62 such short circuits, 38 fires and three injuries reported, prompting Chrysler to recall nearly 900,000 units of the 2011-2014 Jeep Grand Cherokee and Dodge Durango (over 650,000 of them in the United States). The plastic spacers they installed to rectify the problem, however, may not have done the trick. Eight reports (but none involving injuries) have been filed with the NHTSA regarding the same issue recurring, spurring the government agency to open a new investigation into the matter. If deemed necessary, the NHTSA could ask FCA to issue another recall to fix the issue again, which we may necessitate the installation of a fuze to prevent any such the electric short. Related Video: INVESTIGATION Subject : Headliner Fires Date Investigation Opened: MAY 01, 2015 Date Investigation Closed: Open NHTSA Action Number: RQ15003 Component(s): ELECTRICAL SYSTEM , INTERIOR LIGHTING Manufacturer: Chrysler (FCA US LLC) SUMMARY: On July 1st, 2014 Chrysler (FCA US LLC) issued safety recall 14V-391 to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013. The recall was in response to the Office of Defects Investigation (ODI) investigation EA14-001 during which data provided by Chrysler indicates that the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws.

Government Ending Jeep Investigation

The government is closing its investigation into older-model Jeeps with fuel tanks that could rupture and cause fires. The National Highway Traffic Safety Administration said Friday it has "no reservations" with Chrysler Group's plans to recall the vehicles. The agency is expected to release a report on its investigation in a few weeks. The decision ends an unusually public struggle between Chrysler and NHTSA. The agency asked Chrysler to recall 2.7 million Jeeps last June, contending that their gas tanks - which are positioned behind the rear axle - were at risk of rupturing and catching fire in rear-end crashes. Involved were Grand Cherokee SUVs from the 1993 to 2004 model years and Liberty SUVs from 2002 to 2007. Chrysler initially refused to recall the vehicles. The company said the rate of fuel leaks and fires after crashes was similar to comparable vehicles that were sold during the time in question. It was the first time in two years that an automaker had refused NHTSA's request for a recall. Chrysler later agreed to recall 1.56 million of the Jeeps and install trailer hitches on them to help protect the gas tanks. The company sent notices to the remaining customers saying their vehicles were fine if they have factory-installed or Chrysler-made trailer hitches. NHTSA said late Friday that it has been in close contact with Chrysler and will monitor the recall as it continues. Chrysler has told customers that it will start installing the hitches soon. "Consumers should have their vehicles serviced promptly once they receive final notification from Chrysler,"NHTSA said in a statement. In its own statement Friday, Chrysler said, "We share NHTSA's commitment to safety." NHTSA's outgoing chief, David Strickland, told The Associated Press in an interview last month that Chrysler had convinced NHTSA that the Jeeps were no more dangerous than similar vehicles sold at that time. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," Strickland said. Friday was Strickland's last day at NHTSA. He is joining Venable, a law firm. NHTSA began investigating the Jeeps at the request of the Center for Auto Safety, a Washington-based advocacy group. "It is tragic that NHTSA approved Chrysler's sham trailer hitch recall for Jeeps that explode in rear impacts," the Center for Auto Safety's director, Clarence Ditlow, said Friday.