1971 Cj-6, Fully Restored & Customized, 4.3l Gm V6, Auto, Must See, Well-done!!! on 2040-cars

Auto blog

Chrysler taking big risk snubbing NHTSA

Maker Insists Feds Overstate Risk Of Fires With Grand Cherokee, Liberty Models
It's not often that recall stories make it above the fold, in that old newspaper parlance, but when one shows up as the lead story on the network evening news programs, you know it's something big.
And so it is with Chrysler snubbing its nose at a request by the National Highway Traffic Safety Administration to recall 2.7 million Jeeps the feds insist are at risk of potentially catastrophic fuel tank fires in a rear-end collision.

Chrysler resolves recall issue with NHTSA, will inspect, upgrade affected Jeeps

Chrysler made big news earlier in the month by refusing a recall request from the National Highway Traffic Safety Administration for the 1993-2004 Jeep Grand Cherokee and 2002-2007 Jeep Liberty. Last week, NHTSA boss David Strickland countered by defending his agency's request for the recall of 2.7 million Jeep SUVs. Today marked the deadline for Chrysler to formally respond to NHTSA, and it seems that both parties have met in the middle with Chrysler inspecting and upgrading some of the affected vehicles without using the word "recall," which would constitute the admission of a defect; instead, Chrysler said that it is conducting a "voluntary campaign."
At issue on these vehicles is the positioning of the fuel tank behind the rear axle that could get damaged during a rear-end collision. NHTSA has stated that at least 51 people have been killed in rear-end collisions involving these Jeeps after the vehicles caught fire, to which Chrysler countered by pointing out that both models "met and exceeded" the requirements for fuel-system integrity.
As a compromise on the situation, Chrysler says that it will inspect all pre-2004 Grand Cherokees and pre-2007 Liberty models and, "if necessary, provide an upgrade to the rear structure of the vehicle." According to Automotive News, this upgrade will consist of adding a trailer hitch that will presumably better protect the rear-mounted gas tank. Vehicles already equipped with a factory or Mopar hitch will not be modified. Chrysler's official statement on the matter is posted below, but no additional information has been released, such as when the campaign will begin and how many vehicles could be affected.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.