2007 Honda Element Sc on 2040-cars

Auto blog

It turns out Takata isn't willing to expand airbag recall nationally after all

There have been "approximately 0.000006 failures per air bag deployment, which is far below the failure rate" of most recalls, Takata claims. Takata has seemingly made an about face following reports that it would expand its regional airbag recall into a nationwide repair effort, issuing a scathing, four-page letter rebutting allegations by the National Highway Traffic Safety Administration and its Office of Defects while simultaneously attacking the government's handling of the situation. The Japanese supplier claims in its letter that the "currently available, reliable information does not support a nationwide determination of a safety defect," arguing that there were "approximately 0.000006 failures per air bag deployment, which is far below the failure rate in the vast majority of the thousands of recalls," The Detroit News reports. Takata then breaks down the two specific incidents mentioned in NHTSA's original recall request letter, a 2005 Honda Accord and 2007 Ford Mustang. Referencing the two crashes, NHTSA Administrator David Friedman said last month "one incident is an anomaly, but two are a trend." The supplier, though, argues the Honda issue is already being covered by that company's soon-to-be-national recall (more on that in a moment). The company then goes on to point out that neither Takata nor NHTSA has been able to analyze the Mustang's airbag inflator, saying that such a lack of examination meant there was "no way to ascertain what actually occurred during the incident, whether any inflator ruptured, and whether any inflator rupture that may have occurred was related to the incidents that led to the current regional campaigns." Takata alleges that NHTSA has disobeyed its own statutes. Takata also took the opportunity to take a few swipes at NHTSA's behavior during the airbag scandal, saying it was "very surprised to receive" a recall request letter because the ODI had yet to even receive the company's responses to a pair of special orders. It also alleged that NHTSA was disobeying its own statute, which says only manufacturers of vehicles and replacement equipment can "decide in good faith whether their products contain a safety related defect," and that the government can only "issue an initial decision that a safety-related defect exists" to those same entities.

Honda is spending $124 million on a new wind tunnel facility in Ohio

Ford isn't the only company building a multi-million dollar wind tunnel this year. Honda is also getting in on the action. Its new facility will cost less than Ford's at $124 million, and construction begins this summer. It will be built at the Transportation Research Center in Ohio, which is where Honda's NSX proving grounds are located. Honda will install a five-belt rolling road in the tunnel for testing of more pedestrian vehicles, and a wide, high-speed, single belt version for testing of sports cars and race cars. However, it seems the Honda facility will only be capable of testing wind speeds of up to 192 mph, whereas Ford claims a top speed of 200 mph. Cameras and microphones will also be set up inside the testing area at the Honda tunnel to help find wind noise trouble spots. Honda won't necessarily be the only company using the new wind tunnel either. The facility will be available for other groups and companies to use. There are even secure bays those groups can use for their work. Related Video:

VW Finds CO2 'Irregularites', SEMA Recap, and More | Autoblog Minute

Volkswagen's diesel emissions scandal gets a new wrinkle, US regulators hit Takata Corporation with a substantial fine, and we head to Vegas for a look at tuner paradise at the 2015 SEMA show. Autoblog Senior Editor Greg Migliore reports on this edition of Autoblog Minute Weekly Recap. Acura Chevrolet Honda Mazda Mitsubishi Toyota Autoblog Minute Videos Original Video Acura Legend