1996 Honda Acty on 2040-cars

Auto blog

Five vehicles named Top Safety Pick+ including new Civic, MKZ

In an attempt to help push vehicle safety to a higher level, the Insurance Institute for Highway Safety created a stricter Top Safety Pick+ rating last year, which incorporates a brutal small overlap test and requires cars to get Good ratings in four out of the five categories (and no less than Acceptable in the fifth). Joining the list of the safest cars of 2013, the 2013 Volvo XC60, Lincoln MKZ, Honda Civic (sedan and coupe) and the 2014 Mazda6 have all received the coveted TSP+ rating.
The Mazda6 and Lincoln MKZ have both been completely redesigned, and both received Acceptable ratings in the small overlap test. The Honda Civic, coming off its emergency refresh for 2013, is the first small car to be subjected to the small overlap test, and IIHS says that one of the car's many upgrades includes a stiffer front structure allowing it to receive Good ratings in all categories. Similarly, the XC60 gets all Good ratings thanks to, according to IIHS, Volvo updating the airbag software allowing the side airbags to inflate during the small overlap test.
The 2014 Subaru Forester has not yet been subjected to the small overlap test, so it must make do with just a Top Safety Pick rating until the IIHS tests small utility vehicles, which is expected to happen later in the spring.

Honda underreported 1,729 claims of injuries or deaths since 2003

Among these underreported cases were eight Takata airbag inflator ruptures not submitted. Following an independent audit of its safety reporting procedures, Honda has found massive holes in its methodology and practices that resulted in 1,729 claims of injuries or deaths going unreported to federal authorities dating back to July 2003. The cases should have been submitted to the National Highway Traffic Safety Administration as part of its quarterly Early Warning Reports (EWRs) under the TREAD Act, but they fell through the cracks for a variety of reasons. Honda blames the underreporting on three factors: data entry errors, computer coding problems and "an overly narrow interpretation of what constituted a 'written notice' under the TREAD Act." The first two issues were related to the computer program that collected the claims. If employees didn't enter a date in the "written claim received" field, then they were omitted from the EWRs. Also, the company's internal component codes didn't always match those used by NHTSA, and only the ones that were the same were disclosed. Finally, third-party documents, including police reports, were not considered. Honda says the computer error is now corrected, and the company is updating its data entry training. In the future, written and oral claims will be included in EWRs, as well. Among these underreported cases were eight Takata airbag inflator ruptures not submitted in Honda's EWRs, including one death and seven injuries. However, the automaker claims NHTSA was already aware of all of these incidents either from the agency's own records or from the company's notification outside of the EWR process. Unfortunately, this problem could have been stopped much sooner. The issue was first brought to light in 2011 but didn't result in a followup. NHTSA advised the automaker of discrepancies in January 2012, and it still did nothing. This third-party audit wasn't commissioned until September 2014. "Honda acknowledges that it lacked the urgency needed to correct its problems on a timely basis," it says in the announcement. Separately, the Japanese government is starting an investigation, as well. According to Reuters, the Japanese Transport Minister has created a task force to look into the Takata recalls and find out whether Honda under-reported incidents there. Scroll down to read the company's entire statement on the third-party investigation.

Honda CR-Z carbon-fiber prototype

When Honda rolled out the CR-Z a few years ago, it hoped to bridge the gap between those who would save the planet and those who would rather burn all of its resources in a glorious cloud of tire smoke. But enthusiasts recalling the CRX of 1980s vintage balked, imploring Honda to ditch the heavy battery packs and electric motors in favor of a lighter-weight, more conventional powertrain. At this point it seems less likely that Honda would do so at one end of the market than Porsche would ditch the hybrid component of its 918 Spyder at the other. But that doesn't mean Honda isn't still cooking up ways to curb the CR-Z's weight. And it had just one such idea waiting for us when we visited its Japanese R&D center at Tochigi last week.
Nestled in between the JDM hatchbacks, powertrain test mules and new technology prototypes Honda rolled out for us sat the experimental CR-Z you see here. While it may look mostly like the hybrid sport-hatch you can pick up at your local dealer (albeit blacked out), nearly all of this prototype's bodywork has been completely replaced, as have its basic underpinnings, with carbon-fiber reinforced plastic. The exotic material is usually reserved for high-end exotics, but like BMW is democratizing its use in the new i3, so too is Honda researching ways to implement the use of carbon fiber on a mass scale. This one-of-a-kind CR-Z prototype stands, for the time being, as the embodiment of that effort.
Driving Notes