Sle 5.3l Engine Vortec 5.3l V8 Sfi Flexfuel With Active Fuel Management Air Dam on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Ward's releases 10 Best Interiors list for 2014

While we're still a ways off from the automotive awards season proper, where things like North American Car and Truck of the Year, Motor Trend's Car of the Year and Car and Driver's Ten Best are named, that doesn't mean there aren't trophies being handed out to deserving automakers. Ward's 10 Best Interiors being one of them.
As the name might imply, the magazine focuses on the very best interior treatments in the US market. Whereas some awards purposely exclude extreme, high-dollar offerings, Ward's considers them - the only requirement is that a vehicle has a "new or significantly redesigned interior."
Ward's offered up the list of winners in simple, alphabetical order, and it only seems fair to do the same:

GMC Hummer EV recalled over improperly sealed battery pack

Over 700 units of the GMC Hummer EV built during the 2022 and 2023 model years will be recalled due to an improperly sealed battery pack that lets water in. The firm issued a stop-delivery order at the same time as the recall, and it hasn't found how to fix the problem yet. Assigned recall number 22V-771 by the National Highway Traffic Safety Administration (NHTSA), the campaign includes 735 examples of the Hummer EV and 89 units of the BrightDrop Zevo 600 van. These two vehicles are pegged on opposite ends of the automotive spectrum, but they're affected by the same problem: "the high-voltage battery pack enclosure in some of these vehicles may not have been properly sealed," GMC notes, adding that "flanges on the battery pack enclosure may not have been properly primed or electrocoated." Water can wreak havoc in a high-voltage battery pack. GMC told NHTSA that it has found three EVs with this problem: an internal test vehicle that lost power while driving and two customer-owned vehicles that wouldn't start. As of writing, the firm is not aware of any accidents, injuries, or fires related to the issue, and GMC estimates that only about 1% of the recalled EVs are affected. GMC began notifying dealers of the recall in October 2022, and it plans to start reaching out to owners on November 28, 2022. However, a fix hasn't been found yet. In the meantime, the company issued a stop-delivery order and asked dealers not to attempt their own repairs. This isn't the Hummer EV's first run-in with water-related problems. In August 2022, General Motors voluntarily recalled 424 units of the Hummer EV and the Zevo 600 van due to a high-voltage connector that can prematurely corrode. The problem also let water leak into the battery pack, though it sounds like fixing it was reasonably straight-forward and involved applying sealant to the connector. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. Featured Gallery 2022 GMC Hummer EV Edition 1 First Drive View 17 Photos Green GMC Hummer Truck Electric