2011 Ford Shelby Gt 500, Svt. Many Custom Extras! on 2040-cars

Auto blog

Ford, Samsung shack up to bring regen braking to non-hybrid models [w/video]

Ford must be desperate to get itself ready for the beach this summer because it is really trying to get into shape. Shortly after unveiling the Lightweight Concept that cut the weight of a Fusion down to that of a Fiesta, it's now the rest of the line's turn for improvement. The company is wrapping up a 10-year research project aimed at developing next-gen automotive batteries to improve efficiency.
Ford claims that 70 percent of its lineup will have stop/start tech by 2017. The key to this massive proliferation is its new dual-battery system that combines a lithium-ion battery with a lead-acid one and regenerative braking. The setup works by harvesting braking energy and converting it to electricity. When the vehicle stops, the engine shuts off, but the Li-ion battery has enough juice to keep the accessories running. The engine starts up again as drivers take their foot off the brake. The layout would mean less wasted gas while idling. It's already available on Ford hybrids and is somewhat similar to the i-Eloop capacitor-based system from Mazda.
The bigger challenge is tuning the regenerative braking right. While hybrid drivers may be a little more adventurous, when it comes to getting a hang of regen braking, conventional buyers might not be so open-minded. The systems have a tendency to be a little grabby at first and then taper off at very low speeds. Ford needs to make sure it's just right to avoid turning off buyers.

Ford recalls 434k vehicles for several unrelated issues

It seems that the hard winter in much of the country has been as rough on some Fords as it has on many people. The Blue Oval is recalling roughly 434,000 vehicles in two separate recalls, and one of them partially caused by the salt used to melt the snow on roads.
The first recall covers 385,750 2001-2004 Escape models in the Midwest, Northeast and Canada because a subframe could rust and eventually fail. This is partially due to the road salt used in those areas, and about 349,000 of the affected vehicles are in the US. To remedy the problem, dealers are installing a reinforcement cross brace on the frame to strengthen them. There has been one crash caused by the failure but no injuries. According to The Detroit News, this is not the first rust-related recall for Ford. It estimates the company has repaired over two million vehicles since 2010 for problems on vehicles related to the iron oxide, including the rear wheel wells of the Freestar minivan.
The second recall covers 48,950 2013-2014 Ford Fusion, Escape, C-MAX and Lincoln MKZ models because welds in their seatbacks don't meet National Highway Traffic Safety Administration standards. The fault affects the front seats, and the sub-standard welds joining the setback to the recliner could increase the chance on injury. There have been no reported injuries or accidents caused by the problem, but there are 42,972 affected vehicles in the US and 4,744 in Canada.

Ford Police Interceptors win acceleration war against Dodge, Chevy

Just last month, Ford announced its first-ever non-pursuit-rated version of the Police Interceptor sedan for agencies looking to maximize fuel economy, but that doesn't mean that Ford is giving up on chasing down the bad guys. While the Dodge Charger can lay claim to the fastest lap time at the Grattan Raceway test facility held by the Michigan State Police, the results are now in for the Police Vehicle Evaluation acceleration tests. And Ford's Police Interceptor duo (sedan and utility) came out on top.
In the acceleration tests, Ford says that the Taurus-based PI Sedan with the newly available 3.5-liter EcoBoost V6 was the quickest among prospective police cars in both 0-60 and 0-100 mile per hour times. The sedan posted a 0-60 time of 5.66 seconds with all-wheel drive and 5.71 seconds with front-wheel drive, besting V8-powered competitors like the Chevy Caprice and Dodge Charger by more than 0.3 seconds. These rivals close the gap on the AWD sedan in the 0-100 test with the Ford taking 13.5 seconds compared to the Chevy's time of 14.35 and the Dodge's time of 14.7.
As for utility vehicles, the Explorer-based PI Utility, which accounts for 60 percent of Ford's police vehicle sales, essentially went head-to-head with the V8-powered Chevy Tahoe with similar results. Equipped with the new EcoBoost engine option, this big SUV hit 60 mph in just 6.28 seconds and 100 mph in 15.51 seconds compared to times of 8.22 seconds and 21.95 seconds, respectively, for the Tahoe. Other important tests in the PVE include braking and top speed, but while no automakers have stepped up to boast about their numbers in either of these categories, Ford's images show that the V8 Caprice had the highest top speed of the cars at 155 mph while the Tahoe's 139-mph speed made it the fastest utility vehicle.