1964 Ford Resto-mod Station Wagon Country Squire Hot-rod (all-new) Cold Air on 2040-cars

Auto blog

NHTSA investigating 500k Ford and Mercury cars for lighting failures

The Ford Crown Victoria and Mercury Grand Marquis might be long gone as new models in showrooms, but the National Highway Traffic Safety Administration might check them out yet again for a potential problem. At the urging of North Carolina Consumers Council, the agency may open another investigation into the front lighting control module on vehicles from the 2003-2005 model years, and NHTSA estimates the issue could affect 517,945 vehicles. If the module stops working, it can cause a complete failure of all forward lighting, including the headlights. NHTSA previously investigated the issue in 2008 and 2009 but found no need for a recall, according to Bloomberg. Ford also extended the warranty on the part to 15 years or 250,000 miles. To prompt this new request, the North Carolina Consumers Council received a letter from a woman experiencing the module's failure. Upon further investigation, the council found 604 complaints of this problem on NHTSA's website, including seven crashes. Furthermore, the group has alleged that dealers told customers that the parts to perform the replacement weren't available, despite the extended warranty. According to the government agency, "A defect petition has been opened to evaluate the issue and make a grant or deny decision." Ford spokesperson Kelli Felker tells Autoblog via email, "We will cooperate with NHTSA, as we always do." You can read the council's complete letter to the Feds in PDF format, here. INVESTIGATION Subject : Loss of headlamp/exterior lighting Date Investigation Opened: APR 01, 2015 Date Investigation Closed: Open NHTSA Action Number: DP15002 Component(s): EXTERIOR LIGHTING All Products Associated with this Investigation Vehicle Make Model Model Year(s) FORD CROWN VICTORIA 2003-2005 MERCURY GRAND MARQUIS 2003-2005 Details Manufacturer: Ford Motor Company SUMMARY: The Office of Defects Investigation (ODI) has received a petition from the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The petition letter is attached for review. The petitioner alleges a defect in the lighting control module that powers the headlights which can result in the loss of vehicle headlights and/or all exterior lighting while driving. ODI has previously investigated this issue under PE08-066 which was closed without a defect finding.

NHTSA closes probes on Jeep Grand Cherokee, Ford Freestar and Mercury Monterey

The Detroit News reports the National Highway Traffic Safety Administration has officially closed its investigations into 2012 Jeep Grand Cherokee, 2004-2005 Ford Freestar and Mercury Monterey models. The separate probes found no issues that pose safety concerns. NHTSA began investigating certain Grand Cherokee SUVs over complaints that power steering hoses could detach during operation, thereby increasing the risk of a vehicle fire. Of the 24 reports of failure, none alleged smoke or fire in the engine bay, and Chrysler has since modified the power steering cooler assembly to reduce the likelihood of the failure.
Meanwhile, certain Ford Freestar and Mercury Monterey vehicles garnered a government probe after receiving complaints that the models were equipped with faulty scissor jacks. The agency had received six reports of the jacks failing or causing injuries, including one incident that resulted in a fatality. But NHTSA says the jack failure rate is similar to those found in other vehicles. In those six cases, the government agency found the jacks were being used for something other than changing a tire, and investigators could not determine whether the emergency brake was set or the rear tires were properly chocked.

Lexus gets top brand marks from Consumer Reports; Ford, Jeep hit hard

Consumer Reports has released its 2014 Car Brand Report Cards, with Lexus again reigning at the top and doing so with the same industry-topping score of 79 that it registered in last year's Report Cards. This year, the institute credited its lineup for being "usually quiet, comfortable, and fuel-efficient," noting it's the only brand on the list "to achieve an excellent average overall reliability score." The Car Brand Report Cars list is meant to rank the best all-around vehicles based on CR testing and reliability results tallied by subscribers it surveyed. Each brand included must have sufficient test and reliability data for at least three models, a standard which left out 11 marques including Fiat, Jaguar, Land Rover and Porsche.
This 2014 Brand Report Cars edition is the first of a new format in which sub-brands have been broken out from their parent brands, with Acura using this year to move up the leaderboard into second place with a score of 75 for its "reliable, well-finished and somewhat sporty models." The top three was rounded out by Audi, climbing from eighth to third by scoring a 74 for "well-crafted interiors, nice handling and good gas mileage." Audi scored highest in the road-test portion, its improved reliability aiding its rise. The top nine was completed by Subaru, Toyota, Mazda, Honda, Infiniti and Mercedes-Benz.
Ford and Jeep weighed in at the other end of the rankings, Jeep taking the lowest overall score in the road tests and hampered by "a mix of spotty reliability." Ford was sunk by reliability issues with its MyFord Touch infotainment system which consumers found troublesome enough to negate its cars earning "solid test scores" for being "very nice to drive." Perhaps the rumored switch from Microsoft to Blackberry's QNX for the next generation SYNC will help them out. Cadillac's score also took a hit for infotainment reasons after it was the leading US brand last year, the CUE system in the XTS dragging Cadillac to the bottom of all General Motors brands.