2013 Ford Expedition Xlt 964 Miles Loaded!!! on 2040-cars

Auto blog

Ford car-camo artist works his craft on Australia's new Falcon XR8

Ford is among the kings of concealment when it comes to test cars. On one recent Mustang SVT mule, the automaker went to the extreme of putting baffles over the exhausts to hide how many there were. Sounds like a lot of work, right? In a new video, the Blue Oval has decided to take fans behind the scenes to show them what it takes to camouflage a prototype. In this case the subject was the recently unveiled 2014 Falcon XR8 for Australia.
Ford's prototype build coordinator Down Under has the very appropriate name of Neil Trickey, and it's his job to obfuscate the important bits of test cars to keep them out of spy shooters' camera lenses. Trickey calls his job a "dark art," and he shows off some of the tricks of his trade in the video. It turns out that the fabric we often see on mules is a type of lycra, but his team isn't above getting out a can of spray paint to conceal parts, too.
Scroll down to watch a video about a man who you probably wish could be a little worse at his job.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Ford taken to task by gov't for Chicken Tax end-around

Ford is in a bit of a pickle for importing and selling Turkey-built Transit Connect cargo vans as passenger vehicles in the US, then converting them to commercial-vehicle specification stateside in an effort to bypass a 25-percent tax imposed on vehicles imported for commercial use. Automakers are required to pay a 2.5-percent tax on imported passenger vehicles.
The Blue Oval got into trouble for this in a January ruling in which U.S. Customs and Border Protection officials asked Ford to stop the practice of importing the Transit Connect vehicles with passenger seats, then removing and shredding them. Now Automotive News reports that Ford is appealing the ruling. The 25-percent "Chicken Tax," as the tariff is often called, is 50 years old and was enacted as a response to a German tariff on chickens. Like Ford, Chrysler bypasses the higher tariff, but it does so in a different manner. It partially disassembles Sprinter cargo vans before shipping them to the US, then rebuilds them at a plant in South Carolina.
But the ruling against Ford's strategy states that it "serves no manufacturing or commercial purpose" and is there to "manipulate the tariff schedule," Automotive News reports. As Ford's appeal goes through, it is importing the Transit Connect and paying the higher tax, hoping for a favorable outcome and planning to build the next-generation Transit Connect, which it plans to launch before the end of the year, in Spain.