2001 Ford E-350 Econoline Base Stripped Chassis 6.8l on 2040-cars

Auto blog

Ford recalls 434k vehicles for several unrelated issues

It seems that the hard winter in much of the country has been as rough on some Fords as it has on many people. The Blue Oval is recalling roughly 434,000 vehicles in two separate recalls, and one of them partially caused by the salt used to melt the snow on roads.
The first recall covers 385,750 2001-2004 Escape models in the Midwest, Northeast and Canada because a subframe could rust and eventually fail. This is partially due to the road salt used in those areas, and about 349,000 of the affected vehicles are in the US. To remedy the problem, dealers are installing a reinforcement cross brace on the frame to strengthen them. There has been one crash caused by the failure but no injuries. According to The Detroit News, this is not the first rust-related recall for Ford. It estimates the company has repaired over two million vehicles since 2010 for problems on vehicles related to the iron oxide, including the rear wheel wells of the Freestar minivan.
The second recall covers 48,950 2013-2014 Ford Fusion, Escape, C-MAX and Lincoln MKZ models because welds in their seatbacks don't meet National Highway Traffic Safety Administration standards. The fault affects the front seats, and the sub-standard welds joining the setback to the recliner could increase the chance on injury. There have been no reported injuries or accidents caused by the problem, but there are 42,972 affected vehicles in the US and 4,744 in Canada.

Ford, Samsung shack up to bring regen braking to non-hybrid models [w/video]

Ford must be desperate to get itself ready for the beach this summer because it is really trying to get into shape. Shortly after unveiling the Lightweight Concept that cut the weight of a Fusion down to that of a Fiesta, it's now the rest of the line's turn for improvement. The company is wrapping up a 10-year research project aimed at developing next-gen automotive batteries to improve efficiency.
Ford claims that 70 percent of its lineup will have stop/start tech by 2017. The key to this massive proliferation is its new dual-battery system that combines a lithium-ion battery with a lead-acid one and regenerative braking. The setup works by harvesting braking energy and converting it to electricity. When the vehicle stops, the engine shuts off, but the Li-ion battery has enough juice to keep the accessories running. The engine starts up again as drivers take their foot off the brake. The layout would mean less wasted gas while idling. It's already available on Ford hybrids and is somewhat similar to the i-Eloop capacitor-based system from Mazda.
The bigger challenge is tuning the regenerative braking right. While hybrid drivers may be a little more adventurous, when it comes to getting a hang of regen braking, conventional buyers might not be so open-minded. The systems have a tendency to be a little grabby at first and then taper off at very low speeds. Ford needs to make sure it's just right to avoid turning off buyers.

Ford to revisit CVTs?

Today, Ford wishes its first experience with non-hybrid continuously variable transmissions was far behind it. The Blue Oval was awash in complaints and a couple of class-action lawsuits over the CVTs used in its 2005-2007 Ford Freestyle, Five Hundred and Mercury Montego models, which were a manufactured in Batavia, Ohio as part of a joint venture with ZF. The company gave up on the CVT after just two years, but with fuel economy standards pressing automakers to conjure new tricks, Ford's global product development head, Raj Nair, is now saying the transmissions might make a return, "particularly in the low torque applications," says Automotive News. An obvious candidate for CVT consideration is the 1.0-liter Fiesta that can presently only be had with a five-speed manual. Beyond that, the company's 1.6-liter and 2.0-liter four-cylinder engines might fit the bill. Ford hasn't given any indication as to what vehicles it might use to reintroduce the CVT to the US market, or hints about timeline or who would develop it, however. Some CVT trivia: The 1990 Subaru Justy II was the first US passenger car offered with a continuously variable transmission - Subaru called it the ECVT. It handled gearing duties for a 1.2-liter, inline three-cylinder engine that got all of 70 horsepower. A contemporary blurb about the car begins with "Goodness, gracious, great gobs of gimmickry," and goes on to say that "We can't imagine where you would take this car for repairs, but we are certain that the one mechanic in the world who can fix it lives in a very expensive house." The transmission didn't win any fans, but the ECVT and the car have been largely forgotten, while Subaru played the long game and now you'll find its vastly improved Lineartronic CVT on six of the eight models it sells.