1999 Ford E-350 Econoline Club Wagon Xlt Extended Passenger Van 2-door 5.4l on 2040-cars

Auto blog

Ford recalls over 953,000 vehicles to replace Takata airbag inflators

DETROIT — Ford is recalling more than 953,000 vehicles worldwide to replace Takata passenger airbag inflators that can explode and hurl shrapnel. The move includes over 782,000 vehicles in the U.S. and is part of the largest series of recalls in U.S. history. Included are the 2010 Ford Edge and Lincoln MKX, the 2010 and 2011 Ford Ranger, the 2010 to 2012 Ford Fusion and Lincoln MKZ, the 2010 and 2011 Mercury Milan, and the 2010 to 2014 Ford Mustang. Some of the recalls may be limited to specific geographic areas of the U.S. Takata used the chemical ammonium nitrate to create an explosion to inflate airbags. But it can deteriorate over time due to heat and humidity and explode with too much force, blowing apart a metal canister designed to contain the explosion. At least 23 people have been killed worldwide and hundreds injured by the inflators. Ford says it doesn't know of any injuries in vehicles included in this recall. Dealers will replace the inflators. Ford will notify owners about the recall starting on Feb. 18, and the company has replacement parts available for dealers to order, said spokeswoman Monique Brentley. In previous Takata recalls, parts availability had been an issue. Owners can go to this Ford website and key in their vehicle identification number to see if their cars and SUVs are being recalled. The same information will be available soon at the NHTSA recall website. More than three years after the U.S. National Highway Traffic Safety Administration took over management of recalls involving Takata inflators, one third of the recalled inflators still have not been replaced, according to an annual report from the government and a court-appointed monitor. The report says 16.7 million faulty inflators out of 50 million under recall have yet to be replaced. And 10 million more inflators are scheduled to be recalled this month, including the Ford vehicles. Safety advocates said the completion rate should be far higher given the danger associated with the inflators. The recalls forced Takata of Japan to seek bankruptcy protection and sell most of its assets to pay for the fixes. The inflators grow more dangerous as they get older because ammonium nitrate deteriorates due to high humidity and cycles from hot temperatures to cold. The most dangerous inflators are in areas of the South along the Gulf of Mexico that have high humidity. Related Video:

Recharge Wrap-up: Ford 1.0L EcoBoost a hit in Europe; Build a tiny inverter, win $1 million

In Europe, Ford's 1.0-liter EcoBoost engine is the best-selling turbocharged gasoline engine. The three-cylinder motor powers 20 percent of new Fords sold in Europe. Earlier this year, it won its third International Engine of the Year award, and between January and June, it was sold in about 120,000 cars. So far this year, 38 percent of Fords sold in the Netherlands, 35 percent in Denmark and 32 percent in Switzerland have been powered by the 1.0-liter EcoBoost. The engine's turbocharger spins at 248,000 rpm, and provides 24 psi of pressure. The engine produces up to 138 horsepower, depending on the version. Read more in the press release below. When lithium-ion battery packs are retired from the road, remanufacturing, repurposing, and recycling are worthwhile options, according to a study by Mineta Transportation Institute. The study included a cost-benefit analysis of those three options, and found remanufacturing to be the best route. To get the most out of them, batteries should be tested and have their damaged cells replaced then put back to use. Repurposing is the second best option, using the remaining available charge for something besides cars. Recycling on its own isn't profitable, but it could make economic sense with "increased technological breakthroughs." Learn more at Recycling International or download the report here. A smaller inverter for EVs can win you $1 million. The Little Box Challenge is an open competition to build a power inverter with a density of at least 50 watts per cubic inch. Google and the Institute of Electrical and Electronics Engineers (IEEE) are offering the hefty prize to the team that builds the inverter with the highest power density within an enclosed volume of 40 cubic inches. Teams must register by September 30. Read more at Green Car Congress or learn more at the Little Box Challenge website.

Ford, Renault, VW shareholder oppose French aid for PSA/Peugeot-Citro"en

Pots and kettles, glass houses and stones - that's a little of what we appear to have going on in the European car market. New reports say that that three European automakers have registered their opposition to a loan deal that PSA/Peugeot-Citroën is working on with the French government. Peugeot's finance arm, Banque PSA Finance, is struggling with its debts and has been downgraded by Moody's to its lowest investment-grade classification, one step above junk. This makes it more expensive for a potential buyer to finance a car through Peugeot. The last thing Peugeot needs is more difficulty selling cars in the tough European market, and the situation will only worsen if the bank's credit worthiness takes another hit.
A deal being worked on would have the French government offer €7 billion ($9B U.S.) in bonds to guarantee the bank's loans, which would give the institution some breathing room to manage its debts and lower its interest rates. Outside of that, a group of banks would provide other, non-guaranteed loans to the bank to further help its position. In exchange for state help, though, the government wants seats on Peugeot's board for worker representatives and a government liaison, along with factory and worker guarantees. The Peugeot family would maintain control of the company.
So what we have is government assistance being provided to a car company's finance arm, akin to the way General Motors' GMAC (now Ally Financial) and Chrysler Financial got help in their time of need. What we also have is Ford and Renault, and Germany's State of Lower Saxony, the second-largest shareholder in Volkswagen, voicing their concern about the proposal, because they say it could create an unfair competitive advantage for Peugeot. Everyone in Europe's down market is fighting for every sale, and if Peugeot gets help to keep its auto loan costs down, it figures to help buyers choose Peugeot or Citroën.