1995 Ford Aerostar Work Van on 2040-cars

Auto blog

Ford recalls 382k vehicles across six campaigns

Ford needs to repair a total of 381,633 vehicles in North America across six newly announced campaigns, including five safety recalls and one compliance recall. By far the largest of these campaigns covers the 342,271 examples of the 1998-2003 Windstar to double check an earlier recall repair. Among these, 283,413 are in the US and 58,858 are in Canada. The combination of corrosion and stress can cause cracks in the rear axle and eventually lead to the part to snap completely. The company reports a small number of accidents might be connected to this, but there are no injuries. The minivans were recalled for this issue back in 2010, and it was investigated by NHTSA. According to Ford's latest announcement, the reinforcement brackets on some of these models might not have been installed correctly. This time, dealers will perform an inspection. Minivans with incorrectly installed brackets will get a new rear axle. The rest of the owners will be offered a deal to replace the part at a reduced cost. The next largest campaign covers 36,857 examples of the 2015 F-150 to fix a problem with the adaptive cruise control. Specifically, there are 33,481 affected trucks in the US, and 3,376 in Canada. According to Ford, "when passing a large, highly reflective truck" the radar in the system can misidentify a semi as being in the same lane as the pickup. The collision warning system would then activate, slowing the F-150. There's one report of an accident with this happening but no injuries. The fix is simply an update to the adaptive cruise control module software. Ford also has a recall for 1,477 examples of its 2016 F-53 and F-59 stripped chassis models, and they're all located in the US. A manufacturing issue might allow the trucks to shift into reverse without the driver first applying the brakes. There are no reports of any accidents from this, though. To repair the problem, the models get a new transmission shift control bracket and an adjustment to the shift cable. The Blue Oval's safety compliance recall covers 708 examples of the 2016 Fusion and Lincoln MKZ, including 658 of them in the US, 28 in Canada, and 22 in Mexico. On these models, a manufacturing problem with the fuel tank could allow it to crack in a crash, which isn't allowed under federal rules. There are no reports of accidents, injuries or fires. The fix will be a new fuel tank for all of them. The company is also repairing 251 units of the 2015 Taurus and Lincoln MKS, plus the 2016 Explorer.

2020 Ford Explorer safer than old model; crash test ratings short of Top Safety Pick

The 2020 Ford Explorer three-row crossover has improved on the outgoing model in many ways. According to the IIHS, it has also improved in a number of safety categories, but not enough to earn a Top Safety Pick award. The culprit is not the headlight performance for once. The Explorer's headlights were given an "Acceptable" rating, which would be sufficient for Top Safety Pick, if not Top Safety Pick +. Where the Ford falls short is in the front small overlap driver-side crash test, in which it got the second highest "Acceptable" rating. The IIHS requires a "Good" rating in this category, whereas an "Acceptable" rating on the passenger side would be, well, acceptable for Top Safety Pick. According to IIHS, Ford will be reviewing the results to figure out what the issue is, and it will likely make revisions to future Explorers to improve the result. Other than the one test, the Explorer performed admirably. It received a "Good" rating in all other crash categories except the passenger-side small overlap that was not tested. Both its standard and optional forward collision prevention systems had the highest "Superior" ratings, with the standard one preventing a collision with a car at speeds of up to 25 mph, and the optional one avoiding a collision at 12 mph, and "nearly" preventing one at 25 mph. Headlights are rated as "Acceptable" and so is access to child seat LATCH anchors. Also worth noting is that the Explorer's crash test ratings apply to its luxurious twin the 2020 Lincoln Aviator, meaning it also doesn't get a Top Safety Pick rating. The forward collision system performed the same as in the Ford, and the only difference between the two was in headlight performance. The Lincoln's standard headlights, included on the base, Reserve and Grand Touring trims, have the second-lowest "Marginal" rating, but the optional headlights for those trims, and the standard ones on the Black Label trim, received the "Good" rating. Among three-row Explorer competitors, the Honda Pilot, Hyundai Santa Fe XL, Kia Telluride, Nissan Pathfinder and Toyota Highlander all have a Top Safety Pick. The Hyundai Palisade, Mazda CX-9, Subaru Ascent, and the slightly smaller Kia Sorento and Volkswagen Tiguan all have a Top Safety Pick +. As for Lincoln Aviator competitors, the Cadillac XT6, Infiniti QX60, Lexus RX and Volvo XC90 get a Top Safety Pick. The Mercedes-Benz GLE-Class and two-row-only BMW X5 get the Top Safety Pick + rating. Related Video:      

Ford taps Canada-based Multimatic to build carbon fiber Ford GT

Ford has given Canadian firm Multimatic the nod to build the carbon fiber body on the new GT – The Blue Oval says it has worked with this company for 30 years. The global supplier provides parts and engineering to various automakers, and while based in Markham, Ontario it has 12 plants in Canada, the US, Mexico, England, and China. When announcing the decision at the Canadian International Auto Show, Ford says it chose them "because they have specialized equipment for carbon fiber production and expertise in carbon fiber assembly," and we've heard that the 600-horsepower coupe will be produced in a purpose-built facility at Ford's factory in Markham. Even better than that – for GT purposes and for possible hints at a Le Mans run – the Multimatic Motorsports division can be contracted for engineering and race team management. They currently produce the Boss 302R racecar in the Continental Tire SportsCar Challenge, worked on the FR500C, and their Multimatic Motorsports Lola B2K/40 won its class at the 24 Hours of Le Mans in 2000. The first models will roll off the line at the end of next year. Production numbers are rumored to be in the low hundreds, with a six-figure price tag around $200,000. They'll go into production in time for some sort of 50th anniversary celebration of the GT40 taking the the top three spots at Le Mans in 1966. Related Video: Featured Gallery 2017 Ford GT: Chicago 2015 View 30 Photos News Source: CBCImage Credit: Live images copyright 2015 Drew Phillips / AOL Plants/Manufacturing Ford Coupe Luxury Performance Multimatic