2000 Ford Windstar Sel Mini Passenger Van 4-door 3.8l on 2040-cars

Auto blog

Ford recalls over 953,000 vehicles to replace Takata airbag inflators

DETROIT — Ford is recalling more than 953,000 vehicles worldwide to replace Takata passenger airbag inflators that can explode and hurl shrapnel. The move includes over 782,000 vehicles in the U.S. and is part of the largest series of recalls in U.S. history. Included are the 2010 Ford Edge and Lincoln MKX, the 2010 and 2011 Ford Ranger, the 2010 to 2012 Ford Fusion and Lincoln MKZ, the 2010 and 2011 Mercury Milan, and the 2010 to 2014 Ford Mustang. Some of the recalls may be limited to specific geographic areas of the U.S. Takata used the chemical ammonium nitrate to create an explosion to inflate airbags. But it can deteriorate over time due to heat and humidity and explode with too much force, blowing apart a metal canister designed to contain the explosion. At least 23 people have been killed worldwide and hundreds injured by the inflators. Ford says it doesn't know of any injuries in vehicles included in this recall. Dealers will replace the inflators. Ford will notify owners about the recall starting on Feb. 18, and the company has replacement parts available for dealers to order, said spokeswoman Monique Brentley. In previous Takata recalls, parts availability had been an issue. Owners can go to this Ford website and key in their vehicle identification number to see if their cars and SUVs are being recalled. The same information will be available soon at the NHTSA recall website. More than three years after the U.S. National Highway Traffic Safety Administration took over management of recalls involving Takata inflators, one third of the recalled inflators still have not been replaced, according to an annual report from the government and a court-appointed monitor. The report says 16.7 million faulty inflators out of 50 million under recall have yet to be replaced. And 10 million more inflators are scheduled to be recalled this month, including the Ford vehicles. Safety advocates said the completion rate should be far higher given the danger associated with the inflators. The recalls forced Takata of Japan to seek bankruptcy protection and sell most of its assets to pay for the fixes. The inflators grow more dangerous as they get older because ammonium nitrate deteriorates due to high humidity and cycles from hot temperatures to cold. The most dangerous inflators are in areas of the South along the Gulf of Mexico that have high humidity. Related Video:

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

Ford's cars being held up in Chinese ports in trade tensions with U.S.

BEIJING — Ford Motor Co's imported vehicles are being held up at Chinese ports, three people with knowledge of the matter told Reuters, underscoring how U.S. goods are facing increased customs scrutiny in China amid a tense trade standoff. The three people said Ford and Lincoln vehicles were facing unusual delays at customs, with officials asking for extra technical checks. Two of the people said U.S.-made models of some German carmakers, mainly SUVs, being brought into China, were also affected. Ford was being asked to do extra checks on emission components, said a China-based Ford executive familiar with the matter, asking not be named because of the sensitivity of the issue. China's customs agency did not immediately respond to requests for comment. The holdups add to a growing list of American products facing issues at China's borders, as officials try to avert a full-blown trade war. Some trade experts said they believe Beijing is sending a defiant warning to Washington in response to sweeping U.S. trade demands made on China last week. Reuters reported Tuesday that China had ramped up inspections of pork shipped from the United States, after the country's customs agency said it would step up quarantine checks on American apples and logs. The second person, a China-based industry official with knowledge of the matter, said the delays for Ford — as well as some U.S.-made cars from BMW and Mercedes-Benz — had been going on for the last two weeks. "Customs pretends there are technical non-conformities of some nature that won't allow them to clear these U.S.-made cars through customs, but the U.S.-China trade frictions must be the background to this," he said. "Although no one will officially admit it." Responding to a request for comment from Reuters, a BMW spokesman said that "U.S.-made BMW cars have not been delayed at the ports as of last week and before." A Daimler spokeswoman said it was "monitoring the situation closely" regarding ongoing trade talks between China and the United States, but that she could not speculate further on other matters. The third person said the Ford issue, which had been noted by the United States government, and other holdups facing American goods, were clearly related to the trade dispute. A Ford spokeswoman in Shanghai when asked about the matter said: "We are closely monitoring our situation at the port." She declined to comment further.