1941 Ford Other on 2040-cars

Auto blog

Feds looking into Ford Explorer exhaust leak complaints

There may be a burgeoning problem with exhaust leaks in the 2011-2014 model year Ford Explorer. The National Highway Traffic Safety Administration is examining multiple complaints of a gasoline smell in the cabin of these SUVs. However, the exact cause of this problem is still unknown.
"The agency is reviewing all available data and will take appropriate action as warranted," said a NHTSA spokesperson in an email to Automotive News. Owners seem to generally complain on the regulator's website of the smell entering the cabin through the air vents. At this time, the government organization has not yet opened an official investigation into the problem, though. When it does begin inspecting vehicles, NHTSA posts a detailed breakdown of its public data online.
Similar problems have been reported about the Explorer in the past, though. In 2013, Ford issued a recall for the 2013 model year of the SUV due to a fuel leak that could cause drivers to smell a gasoline odor and repaired them again later for another possible leak. In response to Autoblog's questions, Ford responded via email: "We are not aware of a NHTSA investigation. We are currently reviewing the case and in the event that any action is required, we will address it promptly."

Shelby boosts production of 575-hp Raptor on early demand

Shelby American unveiled its all-new Shelby Raptor at the New York Auto Show last month, saying that it would build just 100 examples of its off-road bad boy, a pickup priced at $17,995 over the cost of the donor Ford F-150 SVT Raptor. But the Las Vegas outfit apparently underestimated just how popular the supercharged 575-horsepower 4x4 would actually be.
Strong early demand reportedly has Shelby singing a whole new tune, as the company is now saying it will build upwards of 500 units annually. While the increased production will likely make for at least 400 more happy owners, those who were on the original short list - possibly speculating on future values - might not be grinning as much. Needless to say, the company has assured everyone that each and every one of the modified Raptors will still be listed in the official Shelby registry.
Keep in mind that Ford isn't sitting idle on its trophy-truck-for-the-street, either. The company will reveal its own 2014 F-150 SVT Raptor Special Edition this month.

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.